1 SECTION I 12/05/01 NPR (1987-1995) FIGURE NUMBER INDEX FIG. NO. TITLE PAGE FIGURE NUMBER INDEX I VEHICHLE MODELS AND CHARACTERISTICS TABLE II V. I. N. AND M. D. III HOW TO REFER TO I. D. PLATE IV 0-00 ENGINE OVERHAUL KIT 1-2 0-05 ENGINE GASKET KIT 3 0-10 CYLINDER HEAD COVER 4 0-11 CYLINDER HEAD 5-6 0-12 CYLINDER BLOCK 7-9 0-13 OIL PAN AND LEVEL GAUGE 10 0-14 CAMSHAFT AND VALVE 11-14 0-15 CRANKSHAFT, PISTON AND FLY WHEEL 15-18 0-20 TIMING GEAR CASE AND FLY WHEEL HOUSING 19-20 0-51 OIL PUMP AND OIL STRAINER 21 ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
Transcript
1
SECTION I 12/05/01
NPR (1987-1995)
FIGURE NUMBER INDEX
FIG. NO. TITLE PAGE
FIGURE NUMBER INDEX I
VEHICHLE MODELS AND CHARACTERISTICS TABLE II
V. I. N. AND M. D. III
HOW TO REFER TO I. D. PLATE IV
0-00 ENGINE OVERHAUL KIT 1-2
0-05 ENGINE GASKET KIT 3
0-10 CYLINDER HEAD COVER 4
0-11 CYLINDER HEAD 5-6
0-12 CYLINDER BLOCK 7-9
0-13 OIL PAN AND LEVEL GAUGE 10
0-14 CAMSHAFT AND VALVE 11-14
0-15 CRANKSHAFT, PISTON AND FLY WHEEL 15-18
0-20 TIMING GEAR CASE AND FLY WHEEL HOUSING
19-20
0-51 OIL PUMP AND OIL STRAINER 21
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
2
VEHICLE MODELS & CHARACTERISTICS TABLE 11/21/00
I NPR (1987 – 1995)
M.D
ENGINE
TRANSMISSION MODEL YEAR, VIN (SEQUENTIAL NO.)
NPC7SC 4BD1 3.9L DIESEL
ENGINE (LJ6) 5 SPEED MANUAL
TRANSMISSION (S7N) ’87 H9400001-
NPC7SF 4BD2 3.9L DIESEL
ENGINE (RLW) 4 SPEED AUTOMATIC
TRANSMISSION ’88 J7000001-
NPC7SK V8 GASLOLINE
ENGINE (L05) FOR DIESEL (RMK) ’89 K7000001-
NPC7TF 4 SPEED AUTOMATIC
TRANSMISSION ’90 L7000001-
NPC7TK FOR GASOLINE (MTI) ‘91M7000001-
’92 N7000001- ’93 P7000001-
’94 R7000001- ’95 S7000001-
N P C 7 S C Chassis Type C: Short F: Middle K: Long Cab Type S: Single Cab T: Stripped Chassis Drive 7: USA LEFT HAND DRIVE Driving System C : 4 X 2 Dual Rear Tire n : 4 x 2 Dual Small Rear Tire (Flat Low) P : GVW 5,000 – 7,000 KG N : Light Duty Forward Control Truck ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
3
V. I. N. & M. D.
Vehicle Identification Number (V.I.N.) System
J A L B 4 B 1 K 9 S 7 0 0 0 0 0 0 1
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
MODEL YEAR H FOR 1987 J FOR 1988 K FOR 1989 L FOR 1990 M FOR 1991 N FOR 1992 P FOR 1993 R FOR 1994 S FOR 1995
CHECK DIGIT
CODE ENGINE DESCRIPTION A 5.7L V8 GASOLINE(CPC) H 3.9L DIESEL (4BD1) K 3.9L DIESEL (4BD2-TC)
AXLES CODE DESCRIPTION
1 4X2 2 AXLES 1 DRIVING
CODE MAKER IDENTIFIER JAL UBCINOKETE FOR “ISUZU” J8B INCOMPLETE FOR “CHEV” J8D INCOMPLETE FOR “GMC”
CODE GVWR RANGE
LBS B 10001-14000 C 14001-16000 E 16001-19500 F 16001-19500 H 19501-23500 K 23501-26000 M 26001-33000
CIDE SERIES 4 4000 5 5000 6 6000 7 7000
CODE CAB TYPE A 75 BBC STEEL TILT CAB B 67 BBC STEEL TILT CAB E 105BBC STEEL TILT CAB (CREW CAB)
T STRIPPED CHASSIS BBC: BUMPER TO BACK OF CAB
4
HOW TO REFER TO ID PLATE
• SERVICE PART ID PLATE : locate at the body panel.
}
}
• NOTE :
• Applied Date: Indicated in alpha characters on the ID Plate.
Alpha Character Represent Alpha Character Represent A 0 F 5 B 1 G 6 C 2 H 7 D 3 I 8 E 4 J 9
Example:
Sep. ’94 A J / J E (Month/Year)
0 9 9 4 • M.D.: This column is coded to show the model application of each part. Check the M.D. (Model Designator) on the ID Plate to confirm the correct model if necessary. • Option Code: When the part can not be verified, refer to option codes on the ID Plate
The upper portion of ID Plate shows “Module options and equivalent” such as engine, transmission, grade, body color, interior trim color, etc. The lower portion indicates other specific options.
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
V.I.N. JALC4B1K7S7000004 M.D. NPC7SF AJ/JE ENGINE RLW/4BD2 RR AXLE G73 TRANS. S7N FINAL HC6 TIRE 9ZV B. COLOR/TRIM 729/153 OPTION
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DOES NOT INDICATE THAT ANY PARTS ARE MADE BY THESE MANUFACTURERS.
