Sony Kv-29fv16 Chassis Ba-5

SERVICE MANUAL BA-5 CHASSIS

MODEL COMMANDER DEST CHASSIS NO.

KV-27FV16 RM-Y171 US SCC-S40K-A

KV-27FV16 RM-Y171 CND SCC-S41J-A

KV-29FV16 RM-Y171 E SCC-S38Q-A

KV-29FV16C RM-Y171 E SCC-S38R-A

KV-32FS12 RM-Y168 US SCC-S40F-A

KV-32FS12 RM-Y168 CND SCC-S41F-A

KV-32FS16 RM-Y169 US SCC-S40G-A

KV-32FS16 RM-Y169 CND SCC-S41G-A

r+

on the Remote Commander (press each button within asecond).

Service Adjustment Mode On1. The CRT displays the item being adjusted.

SERVICE HSIZ 0

Disp.(Item)

ItemData

2. Press or on the Remote Commander to select an item.

3. Press or on the Remote Commander to change the data.

4. Press then to save into the memory.

Service Adjustment Mode Memory

1. Press then on the Remote Commander toinitialize.

SERVICE RESET

2. Turn set off then on to exit service adjustment mode.

SECTION 5CIRCUIT ADJUSTMENTS

Carry out step 1 when adjustingIDs 0–4 and when replacingand adjusting IC003.

5-2. MEMORY WRITE CONFIRMATION METHOD1. After adjustment, remove the power plug from the AC outlet,

then plug it in again.

2. Turn the power switch ON and set to service mode.

3. Call the adjusted items again to confirm they were adjusted.

5-3. ADJUSTMENT BUTTONS AND INDICATORS

ELECTRICAL ADJUSTMENTS BY REMOTE COMMANDERUse the Remote Commander (RM-Y168, RM-Y169 or RM-Y171) to perform the circuit adjustments in this section.

NOTE: Test Equipment Required:

• Pattern generator• Frequency counter• Digital multimeter• Audio oscillator

RM-Y171

MUTING POWER

DISPLAY

1

4

8

3

5

6

ENTER

VOLUME

Reg # ITEM FUNCTION RANGEFIX

DATA NTSC 27 PAL M PAL N VIDEO NTSC 32 RF

AVERAGEDATA27FV

AVERAGEDATA32FS

1 HSIZ Horizontal Size Adjustment 0-63 15 12 7 18 11 222 HPOS Horizontal Position Adjustment 0-63 13 8 9 13 20 223 VBOW Vertical Line Bowing Adj. 0-15 9 10 8 9 7 94 VANG Vertical Line Bowing Slant Adj. 0-15 8 10 9 3 9 75 VTRP TRAPEZIUM 0-31 19 14 14 18 21 176 HTRP Horiz. Trapezoid 0-15 6 7 5 6 0 27 TROT Tilt Correction 0-63 31 31 31 31 31 318 PAMP Horizontal PIN distortion Adj. 0-63 19 19 21 27 20 279 UPIN Upper PIN Distortion Adj. 0-63 34 33 36 41 37 3810 LPIN Lower PIN Distortion Adj. 0-63 32 34 40 39 33 3511 VSIZ Vertical Size Adjustment 0-63 32 43 29 51 33 5112 VPOS Vertical Position Adj. 0-63 30 30 32 42 36 3913 VLIN Vertical lineality Adj. 0-15 3 6 10 5 3 414 SCOR Vertical "S" Correction Adjustment 0-15 6 8 10 8 8 815 VZOM 16:9 CRT Z Mode on/off 0-1 0 0 016 EHT Vertical High-Voltage Compensation 0-15 5 5 517 ASP Aspect Ratio control 0-63 47 47 4718 SCRL 16:9 CRT Z Mode Trans. Scroll 0-63 31 31 3119 HBLK Horizontal Blanking on/off 0-1 1 1 120 LBLK Left Blanking Adjustment 0-15 13 13 1321 RBLK Rigth Blanking Adjustment 0-15 8 7 822 HDW Horizontal Drive Pulse Width 1 1 123 EWDC "Parabola" EW, D.C. Adjustment 0-1 0 0 024 LVLN Lower Screen BTM Vertical Line Adj. 0-15 0 0 025 UVLN Uppe Screen BTM Vertical Line Adj. 0-15 0 0 026 INTL INTERLACE 0-3 0 0 027 G2SW 0-1 0 0 028 G2LV 0-7 0 0 029 HOSC Horizontal VCO Oscillation Freq. 0-15 7 7 730 VSS Vertical Sync Slice Level 0-3 0 0 031 HSS Horizontal Sync Slice Level 0-1 0 0 032 HMSK For Macro Vision 0-1 0 0 033 VTMS Select Signal VTIM Pin 0-3 0 0 034 CDMD Vertical Count Down Mode Switching 0-3 * * * 3 3 335 AFC AFC Loop Gain Switching 0-3 0 0 036 FIFR Field Frequency 0-3 ** 3 337 VBLK VBLKW 0-3 0 0 038 REFP REFP 0-1 0 0 039 JPSW JUMPSW 0-1 MENU 0 040 RDRV R Output Drive control 0-63 *** 31 4041 GDRV G Output Drive control 0-63 25 22 4242 BDRV B Output Drive control 0-63 25 21 3143 RCUT R Output Cutoff control 0-63 31 31 3144 GCUT G Output Cutoff control 0-63 15 13 1245 BCUT B Output Cutoff control 0-63 12 14 1546 SCON SUB CONT 0-15 8 11 1147 SHUE Sub HUE adjustment 0-15 16 17 1648 SCOL Sub COLOR adjustment 0-15 16 16 16 17 1849 SBRT Sub BRIGHTNESS adjustment 0-31 16 15 1650 CHUE SUB COLOR (RF) 0-31 7 6 651 CCOL SUB COLOR (RF) 0-31 7 7 7 7 452 UOFS YUV U OFFSET 0-15 7 7 753 VOFS YUV V OFFSET 0-15 7 7 754 RON R Output on/off 0-1 1 1 155 GON G Output on/off 0-1 1 1 156 BON B Output on/off 0-1 1 1 157 AXPL Axis PAL 0-1 0 0 058 AXNT Axis NTSC 0-1 1 1 159 CBPF Chroma BPF on/off 0-1 1 1 160 CTRP Y TRAP FILTER on/off 0-1 1 1 161 COFF Color On/off 0-1 0 0 062 KOFF Set Color Killer 0-1 0 0 063 SSHP Sub SHARPNESS 0-15 5 5 564 SHPF SHARPNESS Circuit Fo 0-3 Palette 2 265 PREL Pre-Shoot/ Over-Shoot 0-1 1 0 066 Y-DC DC transmition Ratio Switching 0-3 Palette 2 267 GAMM Gamma Correction 0-3 Palette 2 268 ABLM ABL Mode Switch 0-1 1 1 169 VTH ABL CD VHT Switching 0-1 1 1 170 YDEL Y Delay Time Control 0-15 7 7 771 NCOL No Color ID 0-1 1 1 172 FSC FSC Out on/off 0-1 1 1 173 K-ID Killer ID Control on/off 0-1 0 0 074 GDOF 0-31 3 3 375 BDOF 0-31 16 16 1676 GCOF 0-31 16 16 1677 BCOF 0-31 7 7 778 SYSC Color System 0-7 4 4 479 VENH Vertical Enhancement 0-7 Palette 5 3

Adjustment Items


DATA NTSC 27 PAL M PAL N VIDEO NTSC 32 RF

AVERAGEDATA27FV

AVERAGEDATA32FS

80 PDSO PDS OFF 0-1 0 0 081 CK CK 0-1 0 0 082 VNL VNL 0-15 3 3 383 HPK HPK 0-1 0 0 084 HPKO HPK OFF 0-1 Palette 0 085 CORE CORE 0-3 2 1 186 TRAP TRAP 0-1 1 1 187 CHTR CH TRAP 0-1 0 0 088 CBPF CBPF 0-1 1 1 189 ENHO ENHOFF 0-1 0 0 090 NMRD NMRD 0-3 0 0 091 YAPS YAPS 0-3 3 3 392 CLKS CLKS 0-3 0 0 093 NSTD NSTDS 0-3 0 0 094 MSS MSS 0-3 0 0 095 KILS KILS 0-3 1 1 196 ADIN ADIN 0-1 0 0 097 EXCS EXCSS 0-3 1 1 198 CPP CPP 0-3 2 2 299 HDP HDP 0-7 4 4 4

100 CDL CDL 0-7 4 4 4101 DYCR DYCOR 0-15 2 2 2102 DYGN DYGAIN 0-15 10 10 10103 DCCR DCCOR 0-15 3 3 3104 DCGN DCGAIN 0-15 6 6 6105 YNRL YNRLIM 0-3 1 1 1106 CNRL CNRLIM 0-3 1 1 1107 WSC WSC 0-3 1 1 1108 VTRH VTRH 0-3 1 1 1109 VTRR VTRR 0-3 1 1 1110 LDSR LDSR 0-3 2 2 2111 VAPG VAPGAIN 0-7 3 3 3112 VAPI VAPINV 0-31 6 6 6113 TEST TEST 0-1 0 0 0114 YPFT YPFT 0-3 3 3 3115 YPFG YPFG 0-15 7 7 7116 CC3N CC3N 0-1 0 0 0117 SELD 0-1 1 1 1118 D2GN D2GAIN 0-7 4 5 5119 YHCR YHCOR 0-3 0 0 0120 YPFC YPFCOR 0-1 0 0 0121 SHT SHT 0-3 0 0 0122 MVT MVT 0-1 0 0 0123 OTT OTT 0-1 0 0 0124 CL2D CL2D 0-1 1 1 1125 CLKG CLKGGT 0-1 0 0 0126 HPLL HPLLFS 0-1 1 1 1127 BPLL BPLLFS 0-1 0 0 0128 FSCF FSCFG 0-1 0 0 0129 PLLS PLLS 0-1 1 1 1130 KILR KILR 0-15 3 3 3131 HSSL HSSL 0-15 12 12 12132 VSSL VSSL 0-15 8 8 8133 BGPS BGPS 0-15 4 4 4134 BGPW BGPW 0-15 10 10 10135 ADCK ADCLKS 0-3 3 3 3136 NDSW NSDSW 0-1 1 1 1137 PFRN FREE_RUN 0-1 0 0 0138 PRVS RVS 0-1 0 0 0139 PCON CONTRAST 0-127 45 45 45140 PUCO U-DAC 0-127 16 16 16141 PVCO V-DAC 0-127 24 24 24142 PHUE 0-31 15 15 15143 PKIL KILLER 1 0 0 0144 PSEP EXT_SC_SEL 0-3 2 2 2145 PHIM 0-1 0 0 0146 PSUB 0-1 0 0 0147 PBGS BG_START 0-63 14 14 14148 PDL0 0-15 6 6 6149 PDL1 0-15 13 13 13150 PBRT Y_OFFSET 0-31 25 25 25151 PVP1 0 0 0152 PUP1 0 0 0153 PVP2 0 0 0154 PUP2 0 0 0155 PVP3 0 0 0156 PUP3 0 0 0157 PACS SET_ACC 0-1 1 1 1158 PSDL SYNC_DELAY 0-3 0 0 0


DATANTSC

27 PAL M PAL N VIDEONTSC

32 RF

AVERAGEDATA27FV

AVERAGEDATA32FS

159 PDCO 0-3 0 0 0160 PCGA C_GAIN 0-1 1 1 1161 PAAF 0-1 0 0 0162 PSU2 0-1 0 0 0163 PCVF 0-1 0 0 0164 PBIT BITSEL 0-1 0 0 0165 PAFC AFCBITSEL 0-1 0 0 0166 PACC ACC_LEVEL 0-63 22 22 22167 PBUR BURST_CLK 0-1 0 0 0168 PEVE EVENUPRA 0-1 0 0 0169 PINW INV_WFF 0-1 0 0 0170 PINR INV_REF 0-1 0 0 0171 PREF RFF_FIX 0-1 0 0 0172 PARE AUTO_REF 0-1 1 1 1173 PAVE AVERAGE 0-1 0 0 0174 PFRA FREE_RUN_ADJ 0-15 0 0 0175 PPAL SUB_PALM_JUDGE 0-255 0 0 0176 PHPO 0-31 6 7 6177 PVPO 0-31 22 22 22178 PHTI HT 0-15 7 9 9179 PHAJ ADJ 0-15 1 1 1180 PBGY BGY 0-15 0 0 0181 PCRO CROSS_SEL 0-1 0 0 0182 PPAR PALRY 0-63 2 2 2183 PHPF HPFOFF 0-1 0 0 0184 PFSC FSC_OUTPUT 0-1 0 0 0185 PVCH SET_VCHIP 0-1 0 0 0186 PVON VCHIP_ONLY 0-1 1 1 1187 PVLN LINE_NUM 0-31 17 17 17188 PVSB STB_DLY 0-255 64 64 64189 PVLV L_LEVEL 0-255 130 130 130190 SBAL Sub Balance 0-7 5 5 5191 SBAS Sub Bass 0-7 0 0 0192 STRE Sub Trebble 0-7 3 3 3193 BBEL BBE Low 0-15 0 **** 0 0194 BBEH BBE High 0-15 0 ***** 0 0195 BBE BBE 0-1 0 ****** 0 0196 AUX SRS, Simulated 0-3 0 0 0 0197 DISP O.S.D Display position 0-127 20 32 34198 HCLW Horizontal Count lower limit 0-255 16 16 16 16199 HCHG Horizontal Count High limit 0-255 64 64 64 64200 ID0 0-255 89 See ID Map201 ID1 0-255 31 See ID Map202 ID2 0-255 79 See ID Map203 ID3 0-255 146 See ID Map204 ID4 0-255 137 See ID Map205 ID5 0-255 19 See ID Map206 ID6 0-255 0 See ID Map

* CDMD = 3 for US & CND, CDMD = 0 for Other** FIFR = 3 for NTSC models, FIFR = 1 for Trinorma models*** 41 for 27FS/32FS families, 31 for 27FV family**** BBEL = 5 for 27FV family; 6 for 29FV family and 0 for 32FS family ***** BBEH = 5 for 27FV family; 7 for 29FV family and 0 for 32FS family****** BBE = 1 for 27FV/29FV families and 0 for 32FS family

SERVICE ID0 25

Notes:

No. 1–206 show the order that each adjustment mode may be selected while in service mode. Data Range shows the range ofpossible settings for each adjustment mode. Initial Data shows the standard settings for each adjustment mode.

Feature ID MapModel Destination ID-0 ID-1 ID-2 ID-3 ID-4 ID-5 ID-6

KV-27FV16 US 89 63 239 146 133 19 7KV-27FV16 CND 89 63 239 178 133 19 7KV-29FV16 E 17 63 255 130 229 19 7

KV-29FV16C E 17 63 255 130 229 19 7KV-32FS12 US 89 31 79 146 137 19 0KV-32FS12 CND 89 31 79 178 137 19 0KV-32FS16 US 89 31 79 146 137 19 7KV-32FS16 CND 89 31 79 178 137 19 7

5-4. MA BOARD ADJUSTMENTS

H. Frequency (Free Run) Check1. Input a TV mode (RF) with no signal.

2. Connect a frequency counter to base of Q501(TP-500 H. DRIVE) on the A Board.

3. Check H. Frequency for 15735 ± 200 Hz

V. Frequency (Free Run) Check1. Select video 1 with no signal input.

2. Set the conditions for a standard setting.

3. Connect the frequency counter to TP-508 (V OUT) orCN501pin (V DY+) and ground on the A Board .

4. Check that V. Frequency shows 60 ± 4 Hz.

Drive (RDRV)1. Input a color-bar signal and set the level to 75%.

2. In Standard mode, set PICTURE to maximum and COLORto minimum.

3. Activate the Service Adjustment Mode.

4. Set both GON and BON items. Using and ; set each tothe following values. Leave RON set to “1”.

SERVICE RON 11: ON0: OFF

R ON: ON (1)G ON: OFF (0)B ON: OFF (0)

5. Connect an oscilloscope probe to CA Board, J701 Pin 12(KR) (Red Out) .

6. Select RDRV with and .

7. Adjust the value of RDRV with and for

92.5 ± 3 VDC.

8. Reset GON and BON values to “1”.

R ON: ON (1)G ON: ON (1)B ON: ON (1)

9. Reset Picture and Color to normal values:

PICTURE: MAXCOLOR: CENTER


Display Position Adjustment (DISP)1. Input a color-bar signal.

2. Set to Service Adjustment Mode.

3. Select DISP with and .

4. Adjust values of DISP with and to adjust charactersto the center.

5. Write to memory by pressing then .

6. Check to see if the text is displayed on the screen.

SERVICE DISP 15

Sub Bright Adjustment (SBRT)1. Input a monoscope signal.


3. Set the PICTURE and BRIGHTNESS to minimum.

4. Select the SBRT item with and .

5. Adjust the values of SBRT with and to obtain a faintlyvisible crosshatch.


Sub Hue, Sub Color Adjustment (CHUE, CCOL)1. Input a color-bar signal and set level to 75%.


3. Connect an oscilloscope probe to CA Board, CN705Pin .

4. Select the CHUE and CCOL item with and .

5. While showing the CHUE item, adjust the waveform with and until the second and third bars show the same level(V2 = V3 < 0.1 Vp-p).

6. While showing the CCOL item, adjust the waveform with and until the first and fourth bars show the same level

(V1 = V4 < 0.1 Vp-p).

��


V. Size Adjustment (VSIZ)1. Input a crosshatch signal.


3. Select the VSIZ item with and .

4. Adjust value of VPOS with and for the best verticalcenter.


V. Center Adjustment (VPOS)Perform this adjustment after performing H. Frequency(Free Run) Check.

1. Input a crosshatch signal.


3. Select the VPOS item with and .

4. Adjust value of VPOS with and for the best verticalcenter.


H. Center Adjustment (HPOS)Perform this adjustment after performing H. Frequency(Free Run) Check.

1. Input a crosshatch signal.


3. Select the HPOS item with and .

4. Adjust the value of HPOS with and for the besthorizontal center.


H. Size Adjustment (HSIZ)1. Input a monoscope signal.


3. Select HSIZ with and .

4. Adjust with and for the best horizontal size.


V. Linearity (VLIN), V. Correction (VSCO),Pin Amp (PAMP), and Horizontal Trapezoid(TRAP) Adjustments1. Input a crosshatch signal.


3. Select VLIN, VSCO, PAMP, and PPHA with with and .

4. Adjust with and for the best horizontal size.


V LINEARITY (VLIN)

V CORRECTION (VSCO)

PIN AMP (PAMP)

HORIZONTAL TRAPEZOID (TRAP)

V. Angle (VANG), V. Bow (VBOW), Upper pin(UPIN) and Low Pin (LPIN) Adjustments1. Input a crosshatch signal.


3. Select VANG, VBOW, UPIN, and LPIN with and .

4. Adjust with and for the best picture.


V ANGLE (VANG)

V BOW (VBOW)

UPPER PIN (UPIN)

LOW PIN (LPIN)

Service Adjustment Mode Memory1. Change the value of the DCOL item to “1”.

2. After completing all adjustments, press then .

Read From Memory

SERVICE READ Green

Red

ENTER

0

SECTION 6DIAGRAMS

6.1 BLOCK DIAGRAM

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

1

2

3

4

1

2

3

4

5

1

3

2

4

6

1

2

1

2

3

1

2

3

4

5

6

7

8

9

10

1

2

3

4

5

6

7

8

9

10

1

2

3

4

5

6

7

8

9

1

2

3

4

5

6

7

8

9

1 3 478910

1

2

3

4

5

1

2

3

4

5

6

7

8

1234

1234

1

2

3

4

1

2

3

4

5

6

7

8

9

1

2

3

4

5

6

7

8

9

1

2

3

4

5

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

1

2

3

1 2

3 4

V

L

R

S

1 234

1

2

3

4

5

7

8

9 10

11

12

14

15

16

17

13

18

1

2

4

3

1

2

3

4

5

6

1

2

3

4

5

1

2

3

1

2

3

1

2

3

4

5

6

7

8

1

2

3

4

5

6

7

1

1

2

3

4

5

6

7

1

12

34

V

L

R

S

1

2

3

4

5

6

7

8

9

10

11

1

2

3

4

5

1

2

1

2

3

CN460

J201

CN406

D2001

T604

RY601

RY602

D626

C636

D622

T602

F601

VDR601

D605

PH600

R645

T505

CN501

T603

T501

T504

CN506

CN2005

CN2006

CN2007

CN2008

CN4001 CN2003T503

CN901

CN902

CN904

CN801

CN800

CN301

CN504

CN515

CN802

CN4200

J4221

CN503

CN2001

CN450

CN451

CN402

CN4050 CN2004

CN602

CN603

CN604

S-VIDEO

4P

SRT

:STAND BY

DGC RELAY

RELAY

AC POWER

D4SB60L-F

AC RECT

D4SB60L-FAC RECT

PHOTOCOUPLER10k

FBT

FRONT

VIDEO 2

VIDEO

MAIN1

ST LED I-STEREN

SAP LED I-SAP

MODE O-SAP

F MONO O-MONO

GND

MAIN2

AFT OUT AFT

RF AGC AGC MUTEAGC

Q101

9V

30V

5V

L OUT

DE-EM OUT

R OUT

MUTE

VOL-CTRL

Q410

C

Y

TV-L

TV-R

FRONT A/V

VIDEO

AUDIO

L

R

V2-L

V2-R

CLOCK

DATA

B-CLK

B-DATA

V1-R

V1-L

YUV-R

YUV-L

AUDIO

L

R

GND

9V

OUT-R

OUT-L

SPK R+

SPK R-

SPK L+

SPK L-

GND

GND

V1

VM

9V

E

NC

+B

VM

1

3

4

5

6 8

9

STANDBY CIRCUIT

D623

Q606

PROTECT

Q605

CONVERTER

SWITCH

Q608

STBY DRIVE

Q607

RELAY DRIVE

Q604

RELAY

DGC

DGC

DGC

DGC DRIVER

Q609

DGC

12V

RECT

LOW B

RECT

AUDIO

RECT

D

VIN

S

OCP/FB

+B

FV

G2

ABL

H5

6

9

8

7

2

4

1

0

0

11

DF

HVH O U T

Q 5 0 2

H D R I V E

Q 5 0 1

HD

HP

I N + 1

EW

I N - 1

P I N D R I V E

P I N O U T

Q 5 0 4

Q 5 0 3

OUT1

I-HLDWN

O U T 2S W

Q 5 0 6 , 5 0 7

I N + 2

VD+

DRIVE+

O U T

GND

I-PROT

R E F

STBY 7.5V

VD-

DRIVE-

ABL

1 2 V 5 V 1 2 V 9 V

POWER SUPPLY

TUNER/IF

AUDIO

MTS

DEFLECTION

DET-OUT

CONVERTER

IC601

5V REG

IC604

9V REG

IC603

ERROR AMP

IC602

IC501

V HOLD

CNTRL

V OUT

IC502

IR DETECT

IC2001

SPR

SPL

+

+

AC IN

TU101

MON-L

MON-R

VAR/FIX-R

VAR/FIX-L

HEATER

6

SPSW

MONITOR

V3

9V

30V

5V

SET5V

SET9V

30V

9V

9V

+B

STBY 7.5V

CN502

A U D I O

L O W B

V C C

+ B+ B

V3-L

V3-R

PIP-L

IR(SENSOR)

POWER-SW

LED-TIMER

GND

V DY+

V DY-

H DY-

H DY-

H DY+

H DY+

YCBCR AUDIO

INPUT

V O L - C T R L

Q 4 1 1

+ B

V C 1

V C 2

M U T E

I N 2

I N 3 +

I N 4 +

I N 1

I N 2 +

I N 1 +

O U T 1 +

O U T 1 +

S T A N D B Y

O U T 3 -

O U T 2 -

O U T 4 +

O U T 2 +

O U T 2 -

O U T 1 -

AUDIO AMP

IC401

AUDIO AMP

IC402

NC

VIDEO

AUDIO

L

R

J202

J203

REAR A/V

SET9V SET9V

J205

AUDIO

L

R

INPUT

J402

REAR VAR/FIX

KEY

POWER-SW

GND

KEY-SWSWITCHES

FUNCTIONPOWER-SW

GND

KEY-SW

S2008

S2007

TP507

TP508

TP 506

A M P

VELOCITY

MODULATION

Q 9 0 3

Q 9 0 4

V M O U T

Q 9 0 5

Q 9 0 6

V M D R I V E

Q 9 0 1

Q 9 0 2

V MVM

9V

E

NC

+B

9V

VM

VM

E

E

QP+

QP+

QP-

QP-

VM

VM

E

E

QP+

QP-

QP-

QP+

D Q P D R I V E

VMOD

VMOD

9VDRIVE

QPDRIVE

Q 8 0 8

Q P H O U T

Q 8 0 7

QP QP VM

VM

9V

VMOD

VMOD

9VDRIVE

QPDRIVE

CONVERGENCE

135V

NC

GND

GND

HP

VD+

DF

+B

9V

Q812IC803

IC802

DF-COMP

HPHP

Q811

Q801

Q803,804 Q802IC801

Q805,806

Q810 Q809

QP DRIVE

SW BUFFER

BUFFER

SW BUFFERV MOD

V MOD

9V

135V

NC

GND

GND

HP

VD+

+B

9V

DF

200V

AUDIO

Y-TO-YUV

CR

CB

GND

V D Y ( + )

V D Y ( - )

H D Y ( - )

H D Y ( + )

Y

PB

PR

J206

Y,PR,PB

INPUT

INPUT

INPUT

FRONT A/V

MENU KEY

CY

GND

GND

NC

FRONT V

FRONT Y

FRONT C

FRONT R

FRONT L

MENU SW

FUNCTION

SWITCHES

GND

NC

FRONT V

FRONT Y

FRONT C

FRONT R

FRONT L

MENU SW

GND

Y2

GND

C2

IR DETECTOR

IR DETECTOR

IC4050 GND

IR SENSOR

STBY 5V

LED-TIMER

LED-MPWR

STBY 5V

GND

IR SENSOR

STBY 5V

LED-TIMER

LED-MPWR

STBY

5V

TV-L

TV-R

V2-L

V2-R

V1-R

V1-L

YUV-R

YUV-L

GND

9V

OUT-R

OUT-L

OUT-B

OUT-A

IN5

IN5A

IN2

IN2A

IN1

IN1A

IN3A

IN3

AUDIO

MON-L

MON-R

VAR/FIX-R

VAR/FIX-L

9V

V3-L

V3-R

MONB

MONA

LINEA

LINEB

IN4A

IN4

AUDIO PROCESSOR

MUTE

NC

M U T E

Q 4 3 0 , 4 3 1

B U F F E R

Q 4 3 2 , 4 3 3

FILTER

IC403AUDIO

PROCESSOR

IC404

L IN

R IN

L OUT R OUT

IN6

IN6A

PIP-L

PIP-R

SCL

SDA

GND

SCL

SDA

DGC

DGC

D G C

NC

27"/29" ONLY

27"/29" ONLY

32" ONLY

32" ONLY

27"/29" ONLY

J204

MONITOR

OUTPUT

VIDEO

AUDIO

L

R

BUFFER

Q201

M U T E

Q 2 0 5 , 2 0 6

BUFFER

BUFFER

Q402

Q401

O C P

Q 5 0 5

S W

Q 6 0 3

Q 6 0 1 , 6 0 2

27"/29" ONLY

27"/29"

ONLY

27"/29"

ONLY

Y1

C1

SDAT

SET9V

30V

SET5V

SCL

STBY

+5V

V2(VIDEO2)

STBY +5V

KEY-SW

MENU-SW

A

B

C

G

I

E

F

H

D

G

B

BA5-882-BD

VD

YOUT

VOUT

VIN

CSYNCS

SDATA

SCLK

PIP

PROCESSOR

IC3301

HD

IC3302

IC3300

VIDEO SW

CHROMA DECODER

BGPS

SWM

UOUT

1

2

3

4

5

6

7

8

9

1

2

3

4

5

6

7

8

9

1

2

3

4

1 2 3 4

1 2 3 4

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

1

2

3

4

1

2

3

4

5

6

7

8

9

10

11

1

2

1

2

3

4

5

6

7

8

9

1

2

3

4

5

6

7

8

9

10

1

2

3

4

5

6

7

8

9

10

1

2

3

4

5

6

7

8

9

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

1

2

3

CN006

CN005

CN004

CN003

CN303

CN304

CN705

CN305 CN3300

CN302

X3500

CN3500

CN002

CN001

CN306

CN401

CN309

20MHz

HP

CONVERG

VD-

HSYNCH SEPBUFFER

AIN

X1001

RESET

SDA

BUFFER

SCL

BUFFER

BUFFER

BUFFER

YOUT

BUFFER

COUT

CKIN

BUFFER

VD+

EW

ABLIN

HD

VMVM OUT

R,G,B OUT

BUFFER

IK BUFFERIKIN

AFCFI

BUFFER

GND

STBY 7.5V

I-PROT

GND

MAIN 1

MAIN 2

AFT

AGC MUTE

Y/C/J

<TUNING CONTROL>

O-MON0

O-SAP

I-SAP

I-STEREN

MUTE

HP

RELAY

DGC

MEMORYDIG COMB

FILTER

Y/C JUNGLE

CONTROL

TUNING SYSTEM

VM

VD-

VD+

EW

ABL

HD

SPSW

MONITOR

V3

SET5V

SET9V

30V

SET5V

SET9V

30V

STBY 7.5V

IR(SENSOR)

POWER-SW

IK

SET9V SET9V

2ND TUNER

AFT OUT

9V

30V

5V

DE-EM OUT

CLOCK

DATA

DET-OUT

9V

30V

5V

MUTE

TU150

IC003

IC001

IC301

Q002 Q006

Q001

FOR JIG

IC002

STBY+5V REG

SW

Q380

Q378,379

SW

ANTENNA

Q365,082

BUFFER

BUFFER

Q004

Q389

Q387,388

Q368

Q303

Q356

X301

Q375

9V

9V

STBY+7.5V STBY+5V

Q305

Q359

Q349,358

Q350,351

Q352,355

Q302,354

Q369,370

Q310

ANT-2

ANT-1

GND

9V

ANT-2

ANT-1

GND

9V

IK

R IN

B IN

G IN

R OUT

G OUT

B OUT

Q701

Q700

1N/S COIL -

N/S COIL +

CN701

N/S MUTE

N/S MUTE

PICTURE TUBE

HV

1 G2

FOCUS

R.G.B DRIVE

CRT DRIVE

KR 12

KB 10

KG 11

CRT DRIVE

IC702

IC1701

2

34

HEATER6

H

CN706

IK

5V

DVD-Y

GND

DVD-B-Y

GDN

DVD-R-Y

9V

VIDEO

GND

GND

MAIN VP

P-B-Y

P-R-Y

P-Y

PYS

DAT

CLK

GND

MAIN SCP

MAIN HP

5V

DVDCB-IN

DVD-YIN

DVDCR-IN

9V

PIP-OUT

PIP-CB-IN

PIP-CR-IN

PIPY-IN

5V

DVD Y

DVD B-Y

DVD R-Y

9V

GND

GND

GND

GND

GND

VIDEO

MAIN VP

P BY

P RY

P Y

P YS

DAT

CLK

MAIN SCP

MAIN HP

5V

BUFFER

Q3320,3321

BUFFER

CS

Q3300,3308

Q3317

Y

U IN

BUFFER

Q3318

Q3301,3315

BUFFER

VINQ3302,3316

Q3319

Y+SYNCH OUT

Y+SYNCH IN

PAL/NTSC 5V

BUFFER

Q3323CVBS

X3300

3.58M

9V

SYNCH SEP

Q3312

SW

Q3313,3314

EY OUT

Q3304

BUFFER

BUFFER

Q3305

Q3306

DRIVE

Q3309

CHROMA DECODER

PIP

Y-TO-YUV

CR

CB

GND

BUFFER

BUFFER

3D COMB FILTER

IC3501

MEMORY

IC3500

RESET

C IN

9V

5V

IN

GND

COMB Y

GND

COMB C

DAT

CLK

GND

GND

Y-IN

GND

Q3504,3505

(I01-I16)

(MI00-MI15)

(MA0-MA7)

(MA0-MA7)

(MA8)

(MA8)

*UCAS

*LCAS MCAS

*WE

*RAS

MWE

MRAS

XO

XI

BUFFERFSCO

FSCIQ3500

SCL

SDA

9V

5V

BUFFER

Q3506AYI

Q3501,3502

Q3503

CSI

BUFFER

BUFFER

Q3501,3502

Q3503

Q3510,3511

Q3512,3513

AYO

ACO

3.3V REG

IC3502

5V3.3V

Y/C SEP

AUTO WIDE

RESET

C IN

9V

5V

IN

GND

COMB Y

GND

COMB C

DAT

CLK

GND

GND

Y-IN

GND

9V

5V

IC302

ALL EXCEPT

KV-32FS12

ALL EXCEPT

KV-32FS12

Q151,152

Q003

BUFFER

Q301

BUFFER

Q304,306

Y2

GND

C2

Y2 IN

C2 IN

RSTB

PIP-L

PIP-R

ALL EXCEPT

KV-32FS12

27"/29" ONLY

32" ONLY

27"/29" ONLY

32" ONLY

27"/29" ONLY

EXCEPT Q305 (IN ALL)

ALL EXCEPT

KV-32FS12

DAT

GND

CLK

HP PROTECTI-HP

I-VPNVTIM

O-N/S

O-MUTE

O-RELAY

I-RMCN

O-DGC

I-POWER

I-HSYNCI-PROT

O-LED

MONOUT

I-CVIN

O-OSC

I-BSC

I-RESET

I-KEY

I-AFT

I-MENU

I-HLDWN

IO-BDAT

IO-BCLKN

SDA

SCLO-SCLN

I-SDAT

O-YM YS2/YM

O-OSDBLCK

O-R

O-G

O-B

R2IN

G2IN

B2IN

O-AGCMUTE

I-BINT

O-MONO

I-STEREN

O-YUYSW YUYSW

O-SAP

I-SAP

Y1

COMB Y

COMB C

C1

ROUT

GOUT

BOUT

I-HLDWN

SDAT

V1

GND

Y1

C1

SCL

GND

STBY +5V

PIP-L

LED

KEY-SW

MENU-SW

V2(VIDEO2)

STBY +5V

GND

N/S

H TRAP

NS MUTE

R

B

G

GND

GND

CVBS4IN

CVBS1IN

CVBS2IN

B-DAT

B-CLK

B-INT

GND

O-ANTSW

VBSSIN

XTAL

H-VD

FSC-OUT

I-AFT2

NS IN

G2FV

N/S DRIVE

N/S

H TRAP

NS MUTE

R

B

G

GND

GND

CVBS3INO-MONSW

C OUT

COMBC IN O-3DRESET

C

D

E

F

G

H

I

A

A BOARD SCHEMATIC DIAGRAM

8

2.4 Vp-p (V)

9

201.2 Vp-p (H)

1

3.4 Vp-p (H)

2

190.5 Vp-p (H)

3

25.9 Vp-p (H)

5

27.9 Vp-p (V)

6

54.3 Vp-p (V)

7

29.0 Vp-p (V)

4

1.08 KVp-p (H)

A BOARD WAVEFORMS

pin volt

D -35.6

G 40.8

S 36.8All voltages are in V

Q605

A BOARD TRANSISTOR VOLTAGE LIST

REF NO. LOC. KV-27FV16KV-29FV16

KV-29FV16CKV-32FS12KV-32FS16 REF NO. LOC. KV-27FV16

KV-29FV16KV-29FV16C

KV-32FS12KV-32FS16

C211 A-7 470 16V 470 # Q205 B-8 2SD601A-QRS-TX 2SD601A-QRS-TX #C212 A-8 4.7 4.7 # Q206 B-9 2SD601A-QRS-TX 2SD601A-QRS-TX #C213 B-8 4.7 4.7 # Q401 B-7 2SB709A-QRS-TX 2SB709A-QRS-TX #C401 B-19 100 100 # Q402 B-6 2SB709A-QRS-TX 2SB709A-QRS-TX #C402 B-17 1000 1000 2200 25V Q502 K-11 2SD2578-YB 2SD2578-YB 2SD2580-YBC435 C-18 .22 25V .22 25V # R218 A-6 100 100 #C507 K-11 17000PF 1.2KV 17000PF 1.2KV 22000PF 1.2KV R221 A-6 220 220 #C511 J-17 1 250V 1 250V .82 250V R224 B-7 4.7K 4.7K #C514 K-11 .68 250V .68 250V .82 250V R225 B-7 4.7K 4.7K #C517 K-11 # # 0.1 R226 B-8 75 75 #C520 K-11 .047 630V .047 630V .051 400V R227 B-8 470K 470K #C530 N-14 0.0022 0.0022 0.001 R228 B-8 470K 470K #C548 J-15 22 160V 22 160V 100 160V R229 B-9 470K 470K #C550 J-17 .1 250V .1 250V .47 250V R231 B-8 6.8K 6.8K #C555 K-11 2700PF 1.2KV 2700PF 1.2KV 4700PF 1.2KV R232 B-8 6.8K 6.8K #C607 H-7 .47 125V .47 300V .47 125V R235 D-6 # # 470KC612 H-11 820 250V # 820 250V R237 C-6 # # 220C615 F-12 # 0.022 # R238 D-6 # # 220C616 F-12 # 220PF # R239 D-6 # # 470KC625 H-16 1000 1000 1000 R401 D-18 20K 20K #C630 H-14 .0047 250V # .0047 250V R402 D-18 10K 10K #C631 H-15 .0047 250V # .0047 250V R403 B-6 4.7K 4.7K #C648 G-6 .22 125V .22 300V .22 125V R404 B-6 4.7K 4.7K #C649 H-15 .0047 500V 0.0047 # R407 B-6 100 100 #C658 H-16 1000 1000 1000 25V R408 B-6 100 100 #C660 H-11 # 330 400V # R420 F-17 # # 3.9KC661 H-11 # 330 400V # R437 E-17 10K 10K 4.7KC699 N-19 .0047 250V # .0047 250V R439 E-17 10K 10K 4.7K

CN503 G-1 9P 9P # R518 L-13 6.8K 6.8K 5.6KCN604 J-1 # # 3P R519 L-12 6.8K 6.8K 5.6K

CN2001 N-5 11P 11P 8P R513 J-17 22 3W 22 3W 10 3WCN2004 K-1 5P 5P # R514 M-12 22K 22K 8.2K

D201 C-10 RD9.1EW-T1 RD9.1EW-T1 # R529 N-14 330K 330K 270KD202 C-11 RD9.1EW-T1 RD9.1EW-T1 # R530 N-14 15K 15K 18KD203 C-10 RD9.1EW-T1 RD9.1EW-T1 # R533 M-16 33K 33K 22KD212 D-5 # # MTZJ-T7710B R534 M-16 36K 36K 33KD213 D-5 # # MTZJ-T7710B R564 M-14 180K 180K 56KD216 C-8 100 100 # R601 H-8 4.7M 1/2W # 4.7M 1/2WD234 B-7 UDZ-TE-17-9.1B UDZ-TE-17-9.1B # R615 I-8 # 8.2M 1W #D235 B-7 UDZ-TE-17-9.1B UDZ-TE-17-9.1B # R627 H-11 390K 270K 390KD236 B-7 UDZ-TE-17-9.1B UDZ-TE-17-9.1B # R628 H-11 # 270K 270KD609 G-12 # RU-1P # R631 F-12 # 100K 3W #

D2001 K-6 # # LNK0120022G R637 H-11 # 5.6K 3W #D2003 C-5 # # RD9.1EW-T1 R638 H-14 33 56 33F601 I-6 6.3A/125V 6.3A/250V 6.3A/125V R646 H-13 1.5K 1.2K 1.5KIC401 B-18 # # TDA7057AQ/N2 R648 E-4 4.7 3W 4.7 3W 33 3WIC402 A-17 TDA8580Q/N1 TDA8580Q/N1 # R660 H-11 15K 3W 5.6K 15K 3WIC502 L-12 TDA8172 TDA8172 STV9379 R662 H-11 # 5.6K 3W #IC601 G-12 STR-F6626 STR-F6656 STR-F6626 R664 F-4 4.7 3W 4.7 3W #IC2001 J-7 # # SBX3081-71 R2001 K-8 # # 2.2KJ202 C-6 # # 3P R2002 K-8 # # 1.5KJ204 A-8 3P 3P # R2004 J-8 # # 6.8K

JW615 G-15 # # 5MM R2005 K-5 # # 0JW616 G-15 # # 5MM S2007 J-7 # # 1-762-816-11JW617 G-15 5MM 5MM # S2008 J-8 # # 1-762-816-11JW618 G-15 5MM 5MM # T504 L-13 1-431-693-11 1-431-693-11 1-435-098-11JW621 J-3 7.5MM 7.5MM # T505 K-18 8-598-834-20 8-598-834-20 8-598-824-10JW622 J-3 7.5MM 7.5MM # T602 H-6 1-435-617-11 1-435-402-11 1-435-617-11L505 J17 150UH 150UH 68UH T603 F-14 1-435-403-11 1-435-402-11 1-435-403-11

PS401 B-17 1-532-686-21 1-532-686-21 1-576-336-21 VDR601 I-6 1-803-585-11 1-803-967-11 1-803-585-11Q201 A-6 2SB709A-QRS-TX 2SB709A-QRS-TX # #: Not Mounted

A BOARD MARK (*) LIST

A BOARD IC VOLTAGE LIST

12 0.0 10 4.1 4 GND 7 2.1 7 5.5 20 5.0

pin volt 13 6.9 11 4.1 5 9.5 pin volt pin volt 8 2.1 21 0.3

1 0.6 12 4.1 6 10.1 pin volt 1 13.3 1 5 9 8.9 22 0.0

2 0.0 pin volt 13 5.2 7 0.1 1 -31.8 2 8.9 2 5 10 4.1 23 0.0

3 2.4 1 6.8 14 6.8 8 14.0 2 -32.7 3 GND 3 GND 11 0.0 24 0.0

4 14.3 2 GND 15 14.1 3 53.2 4 13.3 12 N/C 25 0.0

5 2.4 3 14.1 16 GND pin volt 4 -23.8 pin volt 13 N/C 26 4.5

6 0.0 4 6.8 17 6.8 1 2.1 5 -32.7 pin volt 1 8.6 14 N/C 27 4.5

7 0.6 5 4.3 2 14.0 1 13.3 2 30.7 15 N/C

8 6.9 6 NC pin volt 3 -12.6 pin volt 2 5.0 3 5.1 16 N/C

9 0.0 7 4.1 1 0.2 4 -13.9 1 135.9 3 GND 4 4.9 17 4.7

10 6.9 8 4.1 2 3.7 5 0.2 2 123.4 5 4.9 18 4.4

11 6.9 9 6.8 3 2.5 6 14.3 3 GND 6 GND 19 5.0

IC2001

TU101

All voltages are in V

IC604

IC502

IC602IC501

IC401

IC601

IC603

IC402

pin volt pin volt pin volt pin volt pin volt pin volt

B 0.0 B 4.5 B 0.0 B 134.9 B -32.8 B 0.7

C 5.6 C GND C 93.3 C 1.8 C -23.6 C 0.1

E GND E 0.1 E GND E 135.5 E -32.9 E GND


B 8.6 B 4.5 B -0.1 B 0.0 B -23.6 B 0.0

C GND C GND C 133.0 C 0.0 C -31.2 C 0.7

E 9.0 E 0.2 E GND E GND E -23.6 E GND


B -0.4 B 0.0 B 0.2 B 0.0 B 0.1 B 0.0

C 0.0 C 5.2 C 3.8 C 0.0 C 4.1 C 13.9

E GND E GND E GND E 0.0 E GND E GND

pin volt pin volt pin volt pin volt pin volt

B -0.4 B 5.3 B 0.1 B -33.0 B -36.1

C 0.0 C GND C -6.5 C -33.0 C -35.3

E GND E 5.2 E 0.0 E -33.1 E -36.3

Q101 Q401 Q501 Q505

Q506 Q603

Q205 Q410 Q503 Q507 Q604

Q201 Q402 Q502

Q206 Q411 Q504 Q601 Q606

Q607

Q608

Q609

Q602


A BOARD TRANSISTOR VOLTAGE LIST

Board Board

MA BOARD SCHEMATIC DIAGRAM

— 46 —

1

4.7 Vp-p (H)

2

3.8 Vp-p (8 MHz)

3

0.9 Vp-p (H)

4

0.8 Vp-p (H)

5

1.0 Vp-p (H)

6

4.7 Vp-p (V)

7

3.1 Vp-p (H)

8

2.9 Vp-p (H)

9

2.2 Vp-p (H)

10

1.4 Vp-p (V)

11

1.4 Vp-p (V)

12

3.5 Vp-p (H)

13

3.6 Vp-p (H)

14

4.0 Vp-p (H)

15

3.4 Vp-p (H)

16

3.5 Vp-p (H)

17

1.4 Vp-p (H)

18

1.1 Vp-p (H)

19

1.2 Vp-p (H)

MA BOARD WAVEFORMS

REF NO. LOC.

KV-27FV16KV-29FV16

KV-29FV16C KV-32FS12 KV-32FS16 REF NO. LOC.

KV-27FV16KV-29FV16

KV-29FV16C KV-32FS12 KV-32FS16

C005 F-14 .47 25V # .47 25V Q379 E-19 2SB709A-QRS-TX # 2SB709A-QRS-TX

C151 C-18 1 # 1 Q380 E-19 2SB709A-QRS-TX # 2SB709A-QRS-TX

C153 B-18 0.0047 # 0.0047 R048 J-3 100 # 100

C154 B-19 47 # 47 R069 H-6 220 # 220

C155 C-19 10 # 10 R085 J-3 4.7K # #

C156 C-20 47 25V # 47 25V R089 H-4 220 # #

C157 B-20 100 # 100 R150 D-17 1.5K # 1.5K

C302 L-6 # 0.01 0.01 R151 D-18 100 # 100

C303 L-6 # 0.01 0.01 R154 D-17 560 # 560

C304 L-6 # 0.01 0.01 R155 C-17 560 # 560

C305 L-7 # 100 16V 100 16V R156 B-17 33K # 33K

C306 C-14 1 16V # # R157 C-19 22K # 22K

C307 M-5 # 10PF 10PF R158 C-20 100 # 100

C308 M-6 # 0.01 0.01 R159 B-20 100 # 100

C309 M-6 # 100 16V 100 16V R264 E-19 22K # 22K

C311 M-6 # 180PF 180PF R266 H-18 22K # 22K

C314 K-10 # 15PF 15PF R270 E-18 22K # 22K

C317 K-11 # 0.01 0.01 R271 E-18 22K # 22K

C324 F-15 # 15PF 15PF R272 E-18 22K # 22K

C332 M-5 # 0.0012 0.0012 R275 D-14 # 22K 22K

C336 D-14 # 47 25V 47 25V R277 E-9 2.2M 3.3M 3.3M

C340 L-6 # 100 16V 100 16V R284 C-11 1K # #

C345 I-11 0.01 # 0.01 R285 F-11 1K # #

C346 I-11 0.01 # 0.01 R286 C-14 47K # #

C347 I-11 0.01 # 0.01 R287 C-14 100K # #

C350 L-6 # 0.47 0.47 R288 C-15 470 # #

C351 L-6 # 0.01 0.01 R289 C-15 1K # #

C354 L-6 # 100 16V 100 16V R290 C-15 560 # #

C355 L-6 # 0.01 0.01 R291 C-15 1.5K # #

C366 H-10 # 0.01 0.01 R298 C-4 4.7K # #

C368 M-7 # 0.01 0.01 R299 C-4 220 # #

C369 L-7 # 0.01 0.01 R300 H-13 # 0 0

C380 I-11 # 0.01 # R302 F-11 5MM # #

C381 I-11 # 0.01 # R305 N-6 # 0 0

C382 I-11 # 0.01 # R307 D-10 8.2K # #

C389 E-9 0.033 0.047 0.047 R311 E-12 # 100 100

C390 I-14 # 15PF 15PF R314 E-19 22K # 22K

C391 H-14 # 100 16V 100 16V R316 K-11 # 5.6K 5.6K

C397 M-6 # 0.01 0.01 R317 D-15 # 100 100

C451 A-9 1 16V # 1 16V R318 K-12 # 56K 56K

C452 A-9 1 16V # 1 16V R319 K-12 # 22K 22K

C453 A-9 1 16V # 1 16V R320 K-11 # 100 100

C454 A-9 1 16V # 1 16V R321 K-11 # 560 560

CN001 E-1 11P 8P 8P R328 I-14 # 100 100

CN304 G-20 4P # 4P R331 D-13 # 1K 1K

CN305 J-20 20P # 20P R333 D-14 # 5.6K 5.6KCN306 O-14 15P # # R334 I-14 # 100 100CN401 A-8 2P # 2P R339 D-13 # 56K 56KD303 J-11 1SS133T-77 # 1SS133T-77 R348 F-2 75 # #D304 C-4 MTZJ-T-77-3.3 # # R350 G-2 75 # #FB301 L-7 # 0UH 0UH R351 I-14 # 470 470FL301 I-13 # 1-239-847-11 1-239-847-11 R352 L-5 # 100 100FL302 K-11 # 1-239-847-11 1-239-847-11 R353 L-5 # 100 100FL303 D-14 # 1-239-847-11 1-239-847-11 R354 I-14 # 100 100IC301 G-9 8-752-098-86 8-752-094-98 8-752-098-86 R355 N-5 # 1.5K 1.5KIC302 L-5 # TC90A49P TC90A49P R359 D-14 # 2.2K 2.2KL150 B-19 10UH # 10UH R364 D-13 # 100 100L151 B-20 100UH # 100UH R365 E-12 # 100 100L303 L-5 # 10UH 10UH R366 E-12 # 1.5K 1.5KL304 M-6 # 10UH 10UH R367 K-11 # 2.2K 2.2KL350 L-7 # 10UH 10UH R368 D-14 # 560 560L351 L-6 # 10UH 10UH R369 K-12 # 220 220L356 G-19 0 # 0 R372 K-12 # 560 560L357 H-19 0 # 0 R373 K-12 # 100 100Q151 C-18 2SB709A-QRS-TX # 2SB709A-QRS-TX R374 K-13 # 100 100Q152 C-17 2SD601A-QRS-TX # 2SD601A-QRS-TX R375 K-13 # 1.5K 1.5KQ301 B-4 2SD601A-QRS-TX # # R377 H-13 # 2.2K 2.2KQ302 K-12 # 2SD601A-QRS-TX 2SD601A-QRS-TX R378 I-14 # 0 0Q304 C-15 2SD601A-QRS-TX # # R379 K-12 # 1K 1KQ306 C-15 2SD601A-QRS-TX # # R380 B-4 0 # #Q310 N-6 # 2SB709A-QRS-TX 2SB709A-QRS-TX R381 C-4 6.8K # #Q349 I-14 # 2SD601A-QRS-TX 2SD601A-QRS-TX R386 M-6 # 820 820Q350 E-12 # 2SB709A-QRS-TX 2SB709A-QRS-TX R389 I-13 # 1K 1KQ351 D-13 # 2SB709A-QRS-TX 2SB709A-QRS-TX R392 I-14 # 5.6K 5.6KQ352 D-13 # 2SD601A-QRS-TX 2SD601A-QRS-TX R394 I-14 # 560 560Q354 K-11 # 2SB709A-QRS-TX 2SB709A-QRS-TX R395 I-15 # 560 560Q355 D-14 # 2SB709A-QRS-TX 2SB709A-QRS-TX R396 N-6 # 100 100Q358 H-13 # 2SD601A-QRS-TX 2SD601A-QRS-TX R398 E-9 56K 330K 330KQ359 I-14 # 2SB709A-QRS-TX 2SB709A-QRS-TX R399 E-9 330K 39K 39KQ369 K-12 # 2SB709A-QRS-TX 2SB709A-QRS-TX R434 A-8 4.7K # 4.7KQ370 K-13 # 2SB709A-QRS-TX 2SB709A-QRS-TX R435 A-9 4.7K # 4.7KQ378 E-18 2SB709A-QRS-TX # 2SB709A-QRS-TX TU150 C-18 FSS BTF-FA402 # FSS BTF-FA402

#: Not Mounted

MA BOARD MARK (*) LIST

Board & Boards

CA BOARD WAVEFORMS

1 2 3

132.8V p-p (H) 135.9V p-p (H) 140.6V p-p (H)

REF NO. LOC.

KV-27FV16KV-29FV16

KV-29FV16CKV-32FS12KV-32FS16

R717 A-2 2.2 2W #

R718 A-2 # 3.3 2W#: Not Mounted

( )CA BOARD MARK (*) LIST

H

KG G2

CV KR G1 G4 HV

KB

1 2 3 4 5 6 7 8 9

1

1

2

3

1 2 3 4 5

1

2

3

4

5

6

7

8

9

1

1

3 5

6

7

8

9

1011

12

13

G2

G1-1

H1

H2

G1-2

KB

KG

KR

G1-3

G4

CV

1

2

3

4

5

6

C704

L701 C705

R708

R709

R710

R711R712 R713

D701D702 D703

R714

D704

R715

R716

C707

C702

R707

C708

C701

C703

C709

C710

R702

R701

R705

R700

R720

R721

R719R704

R703

J701

CN702

R706

RV701

CN705

CN701

IC701

Q701

Q700

CN704

IC702

CN706

R717

R718

10

250V

100

100

100

1k1/2W

1k1/2W

1k1/2W

1SS83TD1SS83TD 1SS83TD

100

1/2W

RGP10GPK23

560k1/2W

100k

1/2W

0.00472kVE

0.1

:MPS

1.5:FPRD

0.1:MPS

4725V

4725V

22016V

10

220

10k

10k

22k

2.2k

2.2k

2202W

2.2k

100

4.7250V

:PIN-J

1

VSTAT CONTROL

9P

3P

LA6500-FAN/S AMP

2SC3311ANS MUTE

2SC3311A

NS MUTE

TDA6108JF/N1B

CRT DRIVE

6P

*2W

*2W

G2

TO A BOARD

BIN

GIN

RIN

GND

IK

ROUT

GOUT

BOUT

VDD

TAB (CONTACT)

TO A BOARD

200V

N.C.

GND

HEATER

IK

R

G

B

N/S

N/S MUTE

H-TRAP

GND

GND

(T505)

CRT

E

COIL+

COIL-

NC

N/S COIL

TO A BOARD

(T505)

FOCUS

TO MA BOARD

-13V

+13V

CN502

CN303

RGB DRIVE

CRT DRIVE

TP47R

TP47B

R OUT

B OUT

BA5-885-CA

R

B

G

R

B

G

200V

200V

200V

-13V

-13V

13V

13V

1 2 3

0.0V

0.3V

0.0V

1.7V

0.3V -0.6V0.3V

2.2V

2.0V

2.2V

3.6V

138.5V

134.5V

144.4V

CA BOARD SCHEMATIC DIAGRAM

HX BOARD SCHEMATIC DIAGRAM

1

2

3

R4005 R4004 R4003 R4002

S4002 S4001S4003S4004S4005

S4006

R4001

CN4001

6.8k 2.2k 820 680

100:CHIP

3PWHT-L

:S-MICRO

TV/V

POWER

CH+ CH- VOL+ VOL-

KEY

POWER-SW

GND

KEY-SW

TO A BOARD

CN2003

BA5-885-HX

D BOARD SCHEMATIC DIAGRAM

1234

5 6 7 81234

5 6 7 8

1234

5 6 7 8

1

2

3

4

5

6

7

1 2 3 4

1

1

2

34

6

R801

R802

R803

R804

R805

C801

R806

R807

R808

D802

C802

R809

C803C804R811

R813

R819

R823C807

C808

R827 R828

C809

R830

R831C812

R834 R835

C814

R836

R839R841

T801

R860

C821

R862R863

R864

R865

C823 C824

D813

R867C825

R868

R869

C826

R870

R871

R872

R873

R874

R875

C815

R852

R849R850

R848

C817

R840

R832

R833

R820

R821

C820

C816

D809

C862

R851 C810R853

R815

R814

R822

R825

R829

C818

R817

R812

R842

R824

D814

D808R854

R855

CN801

CN800

CN802

R890

R816

R866

R838

R847

R846

R845

IC802

D812

D810

D811

D801

Q812

Q810

Q809

IC803Q811

IC801

Q804

Q803

Q801

Q802

Q805

Q806

R844

R837

R857

L803

47k:CHIP

10k:CHIP

22k:CHIP

10k:CHIP

4.7k:CHIP

122k

:CHIP

3.3k:CHIP

10k:CHIP

1SS133

10

22k:CHIP

0.22

:PP

0.22

:PP

100

:CHIP

470:CHIP

47k:CHIP

4.7k:CHIP

0.01B:CHIP

0.01:CHIP

4.7k:CHIP

33k:CHIP

0.3316V

:CHIP

0:CHIP1k

:CHIP

0.01:CHIP

4.7k

:CHIP2.2k:CHIP

0.01B:CHIP

2.2k:CHIP

100:CHIP

10k:RN-CP

0.01:CHIP

2.2k:CHIP2.2k

:CHIP

220:CHIP

100k:CHIP

0.0027:PP

0.047:CHIP

1SS133PROTECT

10k:CHIP

0.01:PT

10k:CHIP

100k:CHIP

100p:CHIP

2.2k:CHIP

680k:RN

1M:CHIP

10k:CHIP

330:CHIP

270:CHIP

0.022630V:PP

0.47160V

220p

500V:B

MTZJ-15B

10

5.0MM

JW:RS

681W

4.7k

:CHIP

100k

470k

3.3k:CHIP

3.9k

DF TRANSFORMER

100k

1SS133T-77

1SS133

4P

7P

1P

100k:CHIP

100:CHIP

10k:CHIP

100:CHIP

100k

100k

100k

NJM2903DDF-COMP

ERB44-06CLAMP

ERA38-06CLAMP

ERA38-06DAMP

MTZJ-5.6CCLAMP

2SA1309AHP

2SC3840KSW

2SD601ABUFFER

NJM2903DHP 2SA1309A

QP DRIVE

NJM2904DV-MOD

2SB709ASW

2SB709ABUFFER

2SD601ABUFFER

2SB709ABUFFER

2SB734-T-34V-MOD2SD601A

V-MOD

JW(12.5MM)

12k :RN-CP

10mH:LHL10

+9V

+B

*

*

**

*

*

*

**

*

*:CHIP

*:CHIP

*:CHIP

*:CHIP

*

*

*:CHIP

*:CHIP

135V

GND

H.P

VD+

DF

NC

GND

9V

TO A BOARD

(FOR DF)

QPDRIVE

9VDRIVE

VMOD

VMOD

BA5-885-D

TO A BOARD

CN515

TO V BOARD CN904

CONVERGENCE

CN504

9V

9V9V

+B

+B

pin volt pin volt

1 7.3 1 2.3

2 4.4 2 4.3

3 4.5 3 4.7

4 GND 4 GND

5 4.5 5 7.6

6 4.5 6 6.7

7 4.5 7 6.0

8 9.0 8 9.0All voltages are in V

pin volt

1 6.8

2 5.7

3 0.0

4 GND

5 6.8

6 6.7

7 3.2

8 9.0

IC801 IC803

IC802

D BOARD IC VOLTAGE LIST

REF NO. LOC.

KV-27FV16KV-29FV16


C817 E-2 .0039 630V .0027 630VC818 E-3 .0015 500V 680PF 500VR814 B-8 # 68 1WR817 C-7 56K 47KR820 C-6 22K 33KR821 C-5 15K 3.3KR832 F-4 5.6K 3.3KR833 F-4 33K 39KR840 E-4 68K #R841 E-4 6.8K 10KR848 E-3 15K 1W 2.2K 2WR849 E-3 3.3K 3W 8.2K 3WR850 E-3 # 8.2K 3WR851 E-3 2.2K 2W 6.8K 3WR852 E-2 # 6.8K 3WR854 D-3 6.8K 5.6KR855 D-3 47K 56KR857 D-4 # 33K

#: Not Mounted

D BOARD MARK (*) LIST

pin volt pin volt

B -2.2 B 7.3

C 3.4 C 8.1

E GND E 6.7

pin volt pin volt

B 4.3 B 0.3

C GND C 0.3

E 4.9 E GND

pin volt pin volt

B 6.4 B 0.3

C 4.3 C 1.2

E 7.0 E GND

pin volt pin volt

B 7.4 B 6.3

C 6.4 C GND

E 7.9 E 6.4

pin volt pin volt

B 6.7 B 0.0

C 0.6 C GND

E 7.3 E 0.6


VOLTAGE LIST

Q803 Q810

Q804 Q811

Q802 Q809

Q801 Q806

Q805 Q812

D BOARD TRANSISTOR VOLTAGE LIST

123456789101112131415161718192021222324252627282930

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80

81

82

83

84

85

86

87

88

89

90

91

92

93

94

95

96

97

98

99

100

1 2 3

46 1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

2122232425262728293031323334353637383940

1 3 6

710

2 4 5

912

1 3 6

710

2 4 5

912

I OG

EMI EMI

EMI

R3500

R3501

R3502

R3503

R3504

R3505

C3500

C3501

C3502

C3504

C3505

C3506

C3507

C3509

C3510

C3511

C3512

C3513

C3514

C3515

C3516C3517

C3519

C3520

C3521

C3522

C3524

C3527

C3528

C3529

C3530

C3531

C3532 C3533

C3534C3535

C3536

C3539

C3541

C3542

C3543

C3546

C3547

C3548

C3549 C3550

C3551

C3552

C3553

C3554

C3555

C3556

C3557 C3558

C3559

C3560 C3561

C3562

C3563

C3564C3565 C3566

R3506

R3507

R3508

R3509

R3510 R3511

R3512R3514 R3515

R3516

R3517 R3518

R3519

R3520

R3521

R3522

R3523 R3524

R3525

R3526

R3527

R3528 R3529

R3530

R3531

R3532

R3534

R3535

R3544

R3545

R3547

R3548

R3549

R3550

R3553

R3554

R3555

R3556

R3557

R3558

R3559

R3560R3561

R3563

R3564 R3565

R3566

R3568

R3569

R3570

R3571

R3572R3573

X3500

R3588

FL3500

C3518

C3525

FL3502

FL3503

L3500

L3501

L3502

L3503

L3504

L3505

Q3501

Q3503

Q3505

Q3511

Q3506

Q3512 Q3513

Q3515

Q3516 Q3517

Q3500

Q3504

Q3510

Q3514

Q3502

C3526 C3523

R3551

CN3500FB3500 FB3501

FB3503

FB3504

FB3505

FB3506

FB3507

FB3508

FB3502

FL3504

FL3505FL3506

IC3500

IC3501

IC3502

R3552

R3567

0:CHIP

0

:CHIP

0:CHIP

47

:CHIP

0:CHIP

0

:CHIP

0.1

F:CHIP

15pCH:CHIP

0.1F:CHIP

24pCH:CHIP

24pCH:CHIP

0.1F:CHIP

0.1F:CHIP

0.125V

F:CHIP

390pCH:CHIP

0.125V

F:CHIP

0.1F:CHIP

0

:CHIP

0.01F:CHIP

0.1

F:CHIP

0.1

F:CHIP

3306.3V

0.1F:CHIP

0.1F:CHIP

27pCH:CHIP

47

16V

0.1:CHIP

0.1F:CHIP

0.1

F:CHIP

0.1F:CHIP

4716V

0.1

F:CHIP

10 470pCH:CHIP

115p

CH:CHIP

1

15pCH:CHIP

36pCH:CHIP

10

2.2F:CHIP

15pCH:CHIP

4716V

0.1F:CHIP

4716V

0.01F:CHIP

4716V

0.01F:CHIP

0.01F:CHIP 47

16V

4716V

0.1F:CHIP

0.01F:CHIP

47

16V 0.01

F:CHIP

4716V

0.01

F:CHIP

0.01F:CHIP

4716V

47

16V 0.01

F:CHIP

0.01

F:CHIP

0

:CHIP

0

:CHIP

0:CHIP

1k

:CHIP

470:CHIP

470:CHIP

0

:CHIP100

:CHIP

1.8k:CHIP

1.8k:CHIP

100

:CHIP

100

:CHIP

0:CHIP

4.7k:CHIP

470:CHIP

470

:CHIP

1k:CHIP

47k

:CHIP

2.2k:CHIP

220k

:CHIP

220:CHIP

560:RN-CP

390:RN-CP

5.6k:CHIP

1k:CHIP

100

:CHIP

1k

:CHIP

100

:CHIP

1k

:CHIP

560:CHIP

5.6k

:CHIP

0:CHIP

2.2k:CHIP

820:RN-CP

2.2k:CHIP

820:CHIP

12k

:CHIP

33k:CHIP

1k:CHIP

47

:CHIP

0:CHIP

1k:CHIP

560:CHIP

0:CHIP

0:CHIP

5.6k:CHIP

2.2k

:CHIP

820:CHIP

2.2k:CHIP

33k:CHIP

12k

:CHIP

1k:CHIP 47

:CHIP

20MHz

560:CHIP

0.125V

F:CHIP

0.1

25VF:CHIP

2SD601ABUFF

2SD601ABUFF

2SD601ABUFF

2SD601ABUFF

2SD601ABUFF

2SD601ABUFF

2SD601ABUFF

2SD601ABUFF 2SD601A

BUFF

2SD601ABUFF

2SB709ABUFF

2SB709ABUFF

2SB709ABUFF

2SB709ABUFF

2SB709ABUFF

0.1

:CHIP0.1

F:CHIP

560:CHIP

:CHIP

15P0UH 0UH

0UH

0UH

0UH

0UH

0UH

0UH

0UH

37UH

37UH

37UH

MEMORY

3D COMB/HH DEC

3.3V REG

180

560

:CHIP

5V

9V

9V

9V

9V

5V

5V

5V-2

5V-2

3.3V

3.3V

3.3V-2

3.3V-2

3.3V-2

IO0

IO1

IO2

IO3

IO4

IO5

IO6

IO7

IO0

IO1

IO2

IO3

IO4

IO5

IO6

IO7

IO8

IO9

IO10

IO11

IO12

IO13

IO14

IO15

IO8

IO9

IO10

IO11

IO12

IO13

IO14

IO15

MA4

MA5

MA6

MA7

MA8

MA0

MA1

MA2

MA3

MA0

MA1

MA2

MA3

MA4

MA5

MA6

MA7

MA8

MA7

MA6

MA5

MA4

MA3

MA2

MA1

MA0

MCAS

MWE

MOE

MIO15

MIO14

MIO13

MIO12

MIO11

MIO10

MIO9

MIO8

MIO7

MIO6

MIO5

MIO4

MIO3

MIO2

MIO1

MIO0

DGNDXI

XO

DVDD

HO3

HO2

HO1

HO0

HWCK

HRCK

HRST

DGND

HI3

HI2

HI1

HI0

DVDD

AVDD

FSCO

AGND

AGND

FSC1

CPLL

RPLL

CKMD

DGND

CLK8

RSTB

SLA0

SCL

SDA

ST0

ST1

NSTD

DVDD

DYCO0

DYCO1

DYCO2

DYCO3

DYCO4

DYCO5

DYCO6

DYCO7

DYCO8

DYCO9

ALTF

CSI

TEST

LINE

KIL

DGND

AVDD

CBPC

ACO

AYO

CBPY

AGND

AGND

AYI

VCL

VRBY

VRTY

AVDD

AVDD

VRTC

VRBC

ACI

AGND

MRAS

DVDD

VCC

IO1

IO2

IO3

IO4

IO5

IO6

IO7

IO8

NC

NC

*WE

*RAS

NC

A0

A1

A2

A3

VCC

GNDA4

A6

A7

A8

*OE

*UCAS

*LCAS

NC

IO9

IO10

IO11

GND

IO13

IO14

IO15

IO16

GND

DGND

A5

VCC

IO12

MA8

RESET

C IN

9V

5V

AVDD

Y/C SEP

D5V

A3.3V

D3.3V

9V

5V-2

3.3V

3.3V-2

9V

AUTO WIDE

5V A5V

IN

GND

COMB Y

GND

COMB C

DAT

CLK

GND

GND

Y-IN

GND

BA5-885-BC

CN306

TO MA BLARD

9V

9V

9V

9V

9V

5V

5V

5V

5V

3.3V

3.3V

3.3V

3.3V

3.3-2V

3.3-2V

3.3-2V

3.3-2V

3.3-2V

3.3-2V

3.3-2V

5-2V

5-2V

5-2V

5-2V

3.3-2V

5V

9V

VIDEO

VIDEO

VIDEO

VIDEO

C

C C

C

C

Y

Y

Y

Y

Y

1

2

3

BC BOARD SCHEMATIC DIAGRAM

Board Board

16 1.5 33 1.1 8 1.5 25 0.9 42 0.0 59 4.8 76 3.3 93 3.3

pin volt 17 1.5 34 1.1 9 1.5 26 0.9 43 0.0 60 4.8 77 GND 94 3.3

1 5.0 18 1.5 35 GND 10 1.0 27 0.9 44 0.0 61 NC 78 GND 95 2.0

2 0.8 19 1.5 36 1.1 11 2.9 28 0.8 45 3.3 62 NC 79 0.0 96 NC

3 0.9 20 5.0 37 1.1 12 2.4 29 GND 46 3.3 63 NC 80 GND 97 0.0

4 0.9 21 GND 38 1.0 13 0.3 30 1.5 47 1.8 64 3.3 81 3.3 98 0.5

5 0.9 22 1.6 39 0.1 14 1.1 31 1.6 48 GND 65 0.7 82 1.1 99 1.6

6 5.0 23 1.5 40 GND 15 1.1 32 3.3 49 GND 66 1.5 83 1.7 100 3.3

7 0.8 24 1.5 16 1.1 33 NC 50 1.5 67 NC 84 1.4

8 0.7 25 1.5 pin volt 17 1.1 34 NC 51 0.0 68 NC 85 1.1 pin volt

9 1.4 26 1.5 1 GND 18 1.1 35 NC 52 0.0 69 NC 86 0.0 G GND

10 1.1 27 2.4 2 1.5 19 1.0 36 NC 53 3.3 70 NC 87 0.0 I 5.0

11 NC 28 1.1 3 1.5 20 0.1 37 NC 54 GND 71 NC 88 0.9 O 3.3

12 NC 29 1.1 4 1.5 21 1.1 38 NC 55 GND 72 NC 89 0.9

13 2.9 30 0.0 5 1.5 22 1.4 39 NC 56 NC 73 NC 90 1.0

14 0.5 31 0.3 6 1.5 23 0.7 40 GND 57 3.3 74 NC 91 1.6

15 NC 32 1.1 7 1.5 24 0.8 41 0.0 58 GND 75 NC 92 3.3

IC3500


IC3501 IC3501

BC BOARD IC VOLTAGE LIST

BC BOARD WAVEFORMS

1 2 3

1.5 Vp-p (H) 1.0 Vp-p (H) 0.8 Vp-p (H)

pin volt pin volt pin volt pin volt

B 1.8 B 3.9 B 3.0 B 3.0

C 0.0 C GND C 8.9 C 8.9

E 2.4 E 4.5 E 2.4 E 2.3


B 0.2 B 5.0 B 2.3 B 2.4

C 3.3 C 8.9 C 5.5 C 6.5

E GND E 4.3 E 1.7 E 1.7


B 4.7 B 6.3 B 5.5 B 6.5

C 0.8 C 8.9 C 8.9 C 8.9

E 5.0 E 5.7 E 4.9 E 5.8

pin volt pin volt pin volt

B 3.5 B 1.4 B 1.7

C 4.7 C GND C 0.0

E 3.7 E 2.1 E 2.4

Q3500 Q3504 Q3511 Q3515

Q3501 Q3505 Q3512 Q3516


Q3517

Q3503 Q3510 Q3514

Q3502 Q3506 Q3513

BC BOARD TRANSISTOR VOLTAGE LIST

S

1

2

3

4

5

6

7

8

1

2

3

4

5

1

2

3

4

C901

C902

C903

R901

R902

R903

Q901

R904

D901D902

R905

R906C905

Q902

R907

R908

R909

C907C908C909

C910

R910

C911

Q903

R911

R912

R913Q904

R914

D903R915

R916

R917

R918

R919

R920

R921

R922

C912

C914R923

D806

D805

L802

D804

Q807

L801

D807

C913

R876

R818

R826

Q906

Q905

C906 C904

CN904

CN902

CN901

L901

Q808

C805

C811

2.2

160V

0.047:PT

47010V

47:FPRD

2.7:FPRD

560

:FPRD

2SC4793

VM.DRIVE.2

18k

MTZJ-T-77-39MTZJ-T-77-39

1k:FPRD

18k0.047

200V:PT

2SA1837

VM.DRIVE.1

2.7:FPRD

560

:FPRD

471/2W:FPRD

33

160V47010V

0.0047

500VE

0.1200V:PT

1803W

:RS

10010V

2SC3311AMP

68

220

682SC3311AMP

270

1SS133TEMP-CORR

1k

1k

1k

100

100

820

10k

22:FPRD

47025V

0.047:PT47

1SS133T-77

1SS133T-77

10mH

RGP10GPKG23

IRF614QP-H-OUT

10mH

ERA82-004TP5

0.001

1k

100

2.2k

2SC3311

VM OUT

2SA1309A-QRSTAVM OUT

0.001 :PT 0.001 :PT

4P

8P

5P2SB734

9V DRIVE

*200V

*

200V

VM OUT

E

+B

9V

Q.P.-

Q.P.+

E

VM

Q.P.-

Q.P.+

E

VM

NC

TO A BOARD

V MOD

V MOD

9V DRIVE

QP DRIVECN506

TO D BOARD CN801

QP QP VM

VM

BA5-885-VA

9V

9V

+B

135.4V

134.9V

67.9V 67.9V

0.9V

0.4V

2.4V

1.8V

2.4V

5.4V

1.8V

5.4V5.7V

5.7V

6.1V

6.8V

0.6V

6.4V

6.8V

VA BOARD SCHEMATIC DIAGRAM

REF NO. LOC.

KV-27FV16KV-29FV16


C424 E-2 .47 25V #C425 C-1 1 16V #C426 E-2 1 #C427 C-1 100 #C428 D-2 100 #C429 D-2 0.0047 #C430 D-2 .22 25V #C431 D-2 .1 25V #C432 D-2 0.01 #C433 D-2 1 16V #C434 D-2 .1 25V #C455 E-2 .4725V #C456 E-2 0.01 #C457 E-2 0.033 #C458 E-3 4.7 #C460 E-3 4.7 #IC403 D-1 NJM2198-TE2 #R452 E-2 10K #

#: Not Mounted

K BOARD SCHEMATIC DIAGRAM

1234567891011121314151617181920

21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40

1234567810 91112

13 14 15 16 17 18 19 20 21 22 23 24

1 2 3 4 5 6 7 8 9 10

11

12

13

14

15

16

17

18

19

20

1

2

1 2 3

JW408

JW405

C458

C434C432C430C429C431C433C428

C427

C425

C426

C424

C455C456 C457

R455R456

L410

C475

C446

C448

C447

C440

R433

C460

C490

C444

R403

R404

R408

R409

JR474

R442

R405

R410

C404

C406

R435

R434R436

R438C422

R437

C423

R478

R477

R432

R431

C441

C417

C416

C415

C414

C413

C202

C201

C451

R444

C450

R445

R446

C411C409

CN402

CN451

CN450

R407

C442

JW407

R452

Q431

Q430

Q432

Q433

IC403

IC404

C405C407

C408

C410

C412

C418

C419

R443R440

R441

5MM

100100

0.1

10016V

2.2

2.2

10.0MM

0.125VF

00

0

100

100

100

100

220

220

100

100

0.0033

B:CHIP

0.0015B:CHIP

220

4.7k4.7k

2204.7

220

4.7

220k

220k

10k

10k

100

4.7

4.7

4.7

4.7

4.7

4.7

4.7

4.7

220kCHIP

4.7

220kCHIP

220kCHIP

0.0033

B:CHIP

0.0015 B:CHIP

3P

2P

20P

100:CHIP

0

12.5MM

2SD601AMUTE

2SD601AMUTE

2SB709ABUFFER

2SB709ABUFFER

NJW1130G-TE2AUDIO PROCESSOR

0.033

:CHIP0.22:CHIP

0.22

:CHIP

0.033:CHIP

0.1:CHIP

0.1:CHIP

1:CHIP

10k

CHIP

220k

220k

*

* ** *

*

* *

** *

*

*

*

*

*

* CHIP

* AUDIO FILTER

IN1A

IN2A

IN3A

IN4A

IN5A

IN6A

BBEA

BBEA

TONE

ATONE

B

TONE

ATONE

B

MONA

MONB

LINE

ALINE

B

OUT

OUTB

PS

AGC

AGC

VREF

DAC

DAC

DAC

DAC

SDA

AUX0

SCL

AUX1

GND

VCC IN1

IN2

IN3

IN4

IN5

IN6

BBEB

BBEB

A

TP1

FIL4

FIL5

FIL6

FIL7

FIL8

FIL9

VREF

VREF

V+

GND

MODE1

LIN

RIN

FIL1

FIL2

FIL3

TP3

VOL1

VOL2

LOUT

ROUT

TP2

MODE2

MON-L

MON-R

VAR/FIX-R

OUT-L

OUT-R

9V

GND

YUV-L

YUV-R

V3-L

V3-R

V1-L

V1-R

TV-L

TV-R

V2-R

V2-L

VAR/FIX-L

SDA

GND

SCL

BOARD

N.C.

MUTE

AUDIO PROCESSOR

PIP-L

PIP-R

BA5-885-K

TO MA BOARD

CN401

TO MA

CN402

9V

9V

AUDIO-R

AUDIO-L

AUDIO-L

AUDIO-R

AUDIO-R

AUDIO-RAUDIO-R

AUDIO-R

AUDIO-R

AUDIO-L

AUDIO-L

AUDIO-L

AUDIO-L

AUDIO-L

9V

& Boards & Boards

16 4.5 7 4.7 24 1.3

pin volt 17 4.5 8 4.5 25 1.3

1 NC 18 4.5 9 4.5 26 4.4

2 4.5 19 NC 10 4.5 27 3.9

3 4.5 20 4.5 11 NC 28 4.5

4 4.5 21 4.5 12 4.5 29 4.5

5 4.5 22 4.5 13 4.5 30 NC

6 4.5 23 4.5 14 1.0 31 4.5

7 4.5 24 4.5 15 4.5 32 4.5

8 4.5 16 0.9 33 4.5

9 4.5 pin volt 17 0.9 34 4.5

10 9.0 1 4.5 18 4.8 35 NC

11 GND 2 4.5 19 4.9 36 4.5

12 0 3 4.5 20 GND 37 4.5

13 0 4 4.5 21 8.9 38 4.5

14 NC 5 4.5 22 NC 39 4.5

15 4.5 6 NC 23 NC 40 4.5

IC403

IC404


K BOARD IC VOLTAGE LISTK BOARD MARK (*) LIST

REF NO. LOC.

KV-27FV16KV-29FV16


C805 B-6 .033UF 200V .01UF 630V

C811 A-6 .047UF 200V .082UF 200V#: Not Mounted

VA BOARD MARK(*) LIST


B 0.3 B 0.3 B 4.5 B 4.5

C 0.0 C 0.0 C GND C GND

E GND E GND E 5.1 E 5.2


Q433Q430 Q432Q431

K BOARD TRANSISTOR VOLTAGE LIST

1

0.9 Vp-p (H)

2

3.3 Vp-p (H)

3

1.4 Vp-p (14.3 MHz)

4

3.5 Vp-p (H)

5

3.8 Vp-p (V)

P BOARD WAVEFORMS

12

34

56

78

910

1112

1314

1516

1718

1920

212223

2425

2627

2829

3031

3233

3435

3637

3839

4041

42

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

12

34

56

78

109

1112 13

1415

1617

1819

2021

2223

24

12

34 5

67

8

C3303

C3306

R3328

R3336

R3338

C3323

C3326

L3302L3303

C3327 C3328

D3304

C3334

R3349

R3316

R3317

L3301

R3393

L3304

C3341

C3344

C3352

C3308C3319

C3320

C3339

C3342

C3345

C3346

C3347

C3349

C3350

C3354

C3355

C3356

C3357

R3300

R3303

R3304

R3309

R3310

R3312

R3318R3319

R3320

R3321

R3323

R3324

R3325

R3340

R3341

R3342 R3347

R3350

R3351

R3356

R3361

R3365

R3366 R3367

R3368

R3380

R3382

R3385

R3395

R3396

R3398

R3401

X3300

C3333

C3332

R3375R3371 R3374R3373R3372R3400

R3355

R3376

R3377

R3379

R3403R3378

R3369

R3402

R3383

R3405R3381

R3370

R3404

R3388

R3386

R3387

R3384

R3322

R3399

R3343

R3346

R3344

R3345

R3305

R3335

R3334 R3333

R3311

R3329

R3358R3357

R3359R3360

C3351

C3340

C3343

C3353

C3305

C3301

C3302

C3324 C3325

C3309

C3330

C3304

C3314

C3315

C3336

R3392

L3300

R3313 C3317

C3316

C3311 X3301

C3310 R3308

D3301

R3397

CN3300

C3321

IC3301

Q3300

Q3301

Q3302

Q3308 Q3315

Q3316

Q3319

Q3318

Q3317

C3331

Q3321

Q3320

IC3300

IC3302

Q3311

Q3309

Q3306

Q3305

Q3304

Q3313

Q3314

Q3312

Q3323

C3335

0

47

16V

0.1

25V

F:CHIP

47

16V

47

16V

47

16V

47

16V

0.47

25V

F:CHIP

UDZ-TE-17-3.9B

0

:CHIP

0

:CHIP

0

0

10

1W

0

:CHIP

:CHIP

0.22

25V

F:CHIP

0.22

25V

F:CHIP

0.22

25V

F:CHIP

0.47

:CHIP

470p

CHIP

0.47

:CHIP

470p

CHIP

0.022

:CHIP

1

:CHIP

1

:CHIP

1

:CHIP

0.47

:CHIP

18p

:CHIP

0.022

:CHIP

1

:CHIP

1

:CHIP

1

:CHIP

470

:CHIP

10k

:CHIP

3.3M

100 :CHIP

100

:CHIP

560

CHIP

3.3k

:CHIP0

:CHIP

10k

CHIP

1k

CHIP

1k

:CHIP

220

:CHIP

2.2k

:CHIP

0

:CHIP

2.2k

:CHIP

0 CHIP 1k

CHIP

1k

CHIP

470

:CHIP

470k

:CHIP

680

:CHIP

10k

CHIP

1k

CHIP10k

CHIP

1k

CHIP

560

:CHIP

560

:CHIP

560

:CHIP

39k

:CHIP

22k

:CHIP

820

:CHIP

47k

:CHIP

3.58M

1

:CHIP

1

:CHIP

100

:CHIP

1k

:CHIP

100

:CHIP

1k

:CHIP

1k

:CHIP47k

:CHIP

1k

:CHIP

100

:CHIP

470

:CHIP

1k

:CHIP

47k

:CHIP

1k

:CHIP1k

:CHIP

22k

:CHIP

470

:CHIP

47k

:CHIP470

:CHIP1k

:CHIP

22k

:CHIP

1k

:CHIP

470

:CHIP

1k

:CHIP

680

56k

680

:CHIP

4.7k

680

10k

10k

330

1k

1k 1k

330

220

39k

:CHIP

470

:CHIP

470k

:CHIP1.2k

:CHIP

68p

CH:CHIP

47

47

47

0.01

:CHIP

0.01

F:CHIP

0.01

F:CHIP

0.01

F

0.01

F 0.033

F:CHIP

10

0.01

F:CHIP

0.01 F

0.01 F

0.01F:CHIP

150k :CHIP

:CHIP

270

CHIP

470p

CH:CHIP

470p

CH:CHIP

18p

:CHIP

14.31818

0.22

25V

F:CHIP

33k

CHIP MA111-TX

100 :CHIP

20P

0.001

CHIP

M65664FP-DS60SPIP PROCESSOR

2SD601ABUFFER

2SD601ABUFFER

2SD601ABUFFER

2SB709ABUFFER

2SB709ABUFFER

2SB709ABUFFER

2SD601ABUFFER

2SD601ABUFFER

2SD601ABUFFER

0.001 :CHIP

2SB709A

BUFFER 2SD601ABUFFER

NJM2534M(TE2)VIDEO SW

TDA8501TCHROMA DECODER

2SD12923.3V REG

2SD601ADRIVE

2SB709ABUFFER

2SB709ABUFFER

2SB709AEY OUT

2SD601ASW

2SD601ASW

2SB709ASYNCH SEP

2SD601A

BUFFER

0.0033

CHIP

VIN

VIN

AVDD

VRT

VRB

AVSS

AVDD CSYNCS

FILTER MCK

BIAS DVSS2

X'TAL1 DVDD2

X'TAL2 RESET

X'TAL3 SWMG

AVSS TEST6

HD TEST5

VD FSC

TESTEN BGPM

SCK

BGPS

DVSS1

YADJ DVDD1

YOUT SCLK

AVDD SDATA

ACK

SWMAVSS

UOUT

VOUT

ADJ V

ADJ U

DVD Y

GND

DVD B-Y

GND

DVD R-Y

9V

VIDEO

GND

MAIN VP

GND

P BY

P RY

P YS

DAT

CLK

GND

MAIN SCP

MAIN HP

5V

MCON

H/2

Y

RED

VCC

GREEN

VSS

BLUE

CS

OSC

Y+SYNC OUT

BURST ADJ

Y+SYNC IN

Y+SYNC OUT

NOTCH

PAL/NTSC

CVBS

FLT

CHROMA

VREF

UOFF

VOFF

VIN

UIN

P-Y

TO MA BOARD

CN305

BA5-885-P

VIDEO

VIDEO

VIDEO

VIDEO

VIDEO

VIDEO

VIDEO

5V 5V5V

5V 5V

5V

5V

5V

5V

9V

9V

9V

3.3V

3.3V

3.3V 3.3V

3.3V

3.3V

3.3V 3.3V

1

2

3

4

5

P BOARD SCHEMATIC DIAGRAM

P BOARD IC VOLTAGE LIST29 0.0

pin volt 30 0.0

1 2.6 31 0.0

2 NC 32 0.5

3 NC 33 0.0

4 0.0 34 GND

5 2.6 35 3.1

6 5.0 36 1.1

7 1.8 37 3.0

8 GND 38 1.2

39 2.6

pin volt 40 3.5

1 0.2 41 1.0

2 GND 42 GND

3 4.7

4 4.8 pin volt

5 3.2 1 0.0

6 GND 2 GND

7 0.0 3 0.0

8 GND 4 5.0

9 NC 5 0.3

10 NC 6 2.0

11 GND 7 NC

12 GND 8 5.1

13 3.2 9 NC

14 3.2 10 GND

15 3.2 11 NC

16 GND 12 2.0

17 GND 13 2.5

18 0.3 14 NC

19 GND 15 0.8

20 0.5 16 1.7

21 1.6 17 3.3

22 1.0 18 1.7

23 0.6 19 NC

24 3.4 20 1.7

25 3.4 21 2.5

26 1.4 22 1.7

27 1.7 23 1.3

28 2.0 24 1.9


IC3302

IC3300

IC3301


B 2.4 B 3.0 B 4.1 B 4.2 B 1.9

C 4.2 C GND C 7.7 C 2.4 C 3.8

E 1.8 E 3.7 E 3.5 E 4.8 E 1.3


B 1.6 B 3.1 B 8.8 B 0.0 B 0.0

C 4.2 C GND C 0.7 C 1.9 C 5.0

E 1.0 E 3.8 E 9.0 E 4.9 E GND


B 1.6 B 4.2 B 0.2 B 2.9 B 4.7

C 4.3 C 2.9 C 2.7 C 5.0 C 0.0

E 1.0 E 4.9 E GND E 2.3 E 5.0


B 2.6 B 0.7 B 0.5 B 2.4 B 1.8

C GND C 0.0 C 0.6 C 3.3 C 5.0

E 3.3 E GND E GND E 1.8 E 1.1All voltages are in V

Q3304 Q3309 Q3314 Q3318

Q3302 Q3308 Q3313 Q3317

Q3319

Q3301 Q3306 Q3312 Q3316 Q3320

Q3300 Q3305 Q3311 Q3315

Q3321

Q3323

P BOARD TRANSISTOR VOLTAGE LIST

Date post:	02-Feb-2016
Category:	Documents
Upload:	johnnazde
View:	237 times
Download:	13 times

Sony Kv-29fv16 Chassis Ba-5

Documents