!!!!
!
Wayne&Mallison&Painter&and&Decorator&Pty&Ltd&
ABN:!31!169!646!780!!!!Licence!#!264495C!!!M:!0427!235!776!!!@:[email protected]!
Risk%Score%CalculatorConsequenceConsequence
Likely
hood
Fatal Extensive,Injury
Medical,Treatment First,Aid No,Injury
Likely
hood Common 1 1 1 2 2
Likely 1 1 2 2 2Possible 1 2 2 2 3Not,likely 2 2 2 3 3Rare 2 3 3 3 3
Likelihood/Consequence Risk%ClassThe,hazard,has,the,potential,to:∗ $Permanently$disable$or$kill*$Cause$major$damage$to$structure*$have$a$big$impact$on$the$surrounding$environmentThe,hazard,has,the,potential,to:∗ $temporarily$disable$or$seriously$injure*$cause$some$damage$to$structures*$may$have$some$impact$on$local$environmentThe,hazard,has,the,potential,to:∗ $Cause$only$minor$or$no$injury*$have$little$to$no$impact$on$environment 3
Likely
hood
1
2
Project(Name!
Task/Trade:(Painting!DTo!prepare!and!paint!the!internal!&!External!of!Commerical,!domestic!and!industrial!premises.Including!walls,!Ceilings,!fascias!etc.!
This(SWMS(has(been(developed(by:!Brooke!Mallison!!Approved(by:!Wayne!Mallison!!!!!!!!!!!Position:!Director!Signed:((( Date: !
!
Qualification(and(experience(needed(to(complete(work:(
Specific(training(required(to(complete(this(task:(
PainterD!Can!be!general!labourer!or!fully!qualified!so!long!as!the!training!in!the!next!box!has!been!completed.!!!
White!Card!!Manual!Handling!Induction!Site!specific!Induction!MSDS!Induction!Tool!box!talk!
Safety(Legislation(/(Code(s)(of(practice(applicable(to(the(project:(Work%Health%&%Safety%Act%2011%Work%Health%&%Safety%Regulations%2011,%AS4361.2%1998%Guide%to%Lead%paint%managementG%Residential%and%Commercial%Buildings,%AS/NZS4576%Guidelines%for%scaffolding,%AS1576.1/1995%ScaffoldingGGeneral%Requirements,%AS/NZS3000%Electrical%Installations.%
!!!!
!
Wayne&Mallison&Painter&and&Decorator&Pty&Ltd&
ABN:!31!169!646!780!!!!Licence!#!264495C!!!M:!0427!235!776!!!@:[email protected]!
Job(Step( Procedure( Potential(Hazard(
Risk(Class(
Controls( Person(Responsibl
e(Preparation!for!painting,!sanding!and!patching!
•!Attend!site!specific!induction!
•!Install!any!warning!signs!
•!Apply!painters!tape!or!film!!
Manual!Handling!Injuries!Dust!!
2( •! Manual!Handling!training,!use!of!correct!lifting!techniques!as!set!out!in!book.!
•! Wear!PPE!gear!
All!Employees!
Platform!Ladder!or!Scaffold!use!
•!Erect!Scaffolding!•!Set!up!of!platform!ladders!
Falls!Uneven!Surfaces!Incorrect!Set!up!
1( •!Use!only!approved!equipment!
•!Scaffold!over!4m!to!be!erected!by!qualified!employee!
All!employees!
Applying!paint! •!Prepare!surfaces!•!Apply!undercoat!!•!Apply!top!coat!
Falls!Dust!Inhalation!Skin!Irritation!Straining!Paint!Inhalation!
2( •!Correct!manual!handling!•!Correct!use!of!equipment!
•!Use!of!PPE!Gear!•!Ventilation!
All!employees!
Use!of!power!cords!and!leads!Electrical!Tooling!
•!Check!cords!/tooling!is!tagged!
•!Inspect!cords/tooling!for!any!signs!of!wear!
Electrocution!Burns!Explosion!Sparking!
1( •!Don’t!overload!outlets!•!Cords!are!not!to!be!tangled!or!laid!in!walkways!
•!Test!and!tag!all!tooling/cords!
All!employees!
Working!with!an!elevated!platform!ie.!scissor!or!boom!lift!
•!Work!area!to!be!cleared!of!hazards!
•!Inspection!of!machinery!prior!to!use!
•!Operation!only!by!competent!persons!
•!Work!from!platform!safely!
•!Area!to!be!barricadied!off!from!all!predestraians!
Falls!Trips!Fatality!Machine!Tipping!Injury!to!bystanders!Falling!objects!Unauthorized!usage!
1( •!Keep!work!area!clean!•!Use!only!on!stable!ground!
•!Inspection!of!machinery!to!be!kept!up!to!date!
•!Do!not!use!with!any!broken!or!missing!parts!
•!Harnesses!to!be!used!•!Qualified!operator!to!use!•!No!‘mucking’!about!while!using!machinery!
•!No!usage!other!than!manufacturer’s!specifications!
All!Employees!
Spray!Painting!/!Confined!space!painting!
•!Barricade!area!•!Erect!any!warning!signs!
•!Wear!PPE!Gear!
Respiratory!Problems!Skin!irritation!Eye!irritation!Inhalation!of!fumes!!
2( •!Wear!applicable!PPE!gear!
•!Ventilate!area!as!much!as!possible!!
All!employees!
General(Risk(Assessment(
!!!!
!
Wayne&Mallison&Painter&and&Decorator&Pty&Ltd&
ABN:!31!169!646!780!!!!Licence!#!264495C!!!M:!0427!235!776!!!@:[email protected]!
!
!
!
!
!
After!use! •!Collect!all!equipment!
•!Leave!job!site!in!a!clean!manner!
•!Pack!away!all!materials!or!correctly!store!for!future!use!
Falls!/!trips!Environmental!Chemical!Hazards!!
2( •!Store!materials!as!per!MSDS!sheets!
•!Pack!away!all!tooling/cords/materials!
•!Collect!all!rubbish!and!dispose!of!properly!
All!employees!
Washing!of!Brushes,!rollers!and!other!implements!
•!Clean!brushes!etc!!
Skin!Irritation!Environmental! 3( •!Use!gloves!to!clean!
brushes!if!irritation!common!
•!Brushes!to!be!cleaned!in!appropriate!on!site!area!or!taken!back!to!shed!for!cleaning!
•!Wear!PPE!to!prevent!paint!in!eyes!
•!Use!of!chemical!cleaners!to!be!used!in!accordance!with!manufacturer’s!!specifications!
All!Employees!
Activity( Environmental(Aspect(
Environmental(Impact(
Risk(Occurrence(
Risk(Impact( Preventative(Measures(
Applying!Sealer! Spills! Water!Pollution!Soil!pollution! 2( 2( Do!not!store!near!drains!
Wipe!up!any!spills!asap!Do!not!rinse!down!drains!Do!not!tip!onto!dirt!or!grass!
Applying!paint! Spills!Waste!
Water!Pollution!Soil!pollution! 1( 1( Wipe!up!spills!asap!
Do!not!wash!down!drains!Do!not!tip!onto!soil!or!grass!Recycle!tins!
Clean!up!! Water!usage! Water!Pollution!Soil!Pollution! 3( 2( No!wash!up!of!
implements!to!be!done!on!site!Use!disposable!brushes!!
Sanding! Dust! Air!Pollution! 2( 2( Use!of!vacuum!sander!to!reduce!dust!particles!
Environmental(Risk(Assessment(
!!!!
!
Wayne&Mallison&Painter&and&Decorator&Pty&Ltd&
ABN:!31!169!646!780!!!!Licence!#!264495C!!!M:!0427!235!776!!!@:[email protected]!
!
Toolbox / Pre-start Talks
Workplace:
Subject of Talk:
Presented by:
Duration: Date:
Persons Present
Print Name: Signature: Print Name: Signature:
Points Raised / Comments:
Corrective Action Action by Action Complete
Sign off Date
!
!!!!
!
Wayne&Mallison&Painter&and&Decorator&Pty&Ltd&
ABN:!31!169!646!780!!!!Licence!#!264495C!!!M:!0427!235!776!!!@:[email protected]!
!
This!safety!plan!provides!details!on!how!as!the!trade!contractor!we!will!manage!the!health!and!safety!hazards!associated!with!our!work!on!the!builders!sites.!
!We!have!consulted!with!the!principal!contractor!and!have!agreed!with!the!controls!listed!in!
the!plan.!!!!!!!!!!!!!!!Wayne!Mallison! ! ! !!!!!!!!!!! ! ! !
!
!
!
!!!!!!!!!!Employee’s!to!sign!that!they!herby!agree!and!will!abide!all!OH&S!Policies!whilst!!!!!!!!!!!!on!this!site!as!set!out!in!this!book.!!!!!!!!!!!!!!!!!!!!!!!Name____________________Sign________________Date_________________!!!!....................................................................................................................................................!!!!!!!!!!!!!!!Name____________________!Sign_______________Date__________________!!!....................................................................................................................................................!!!!!!!!!!!!!!!Name____________________Sign_______________Date___________________!!....................................................................................................................................................!!!!!!!!!!!!!!!Name____________________Sign_______________Date___________________!!
!
!
!
!
! !
White(Card(Register(!
Name! Card!#!! !! !
!!!!!!!!!!!!!!Date!Supervisor’s!Signature!Supervisor’s!Name!
!!! !!
!
! Wayne!Mallison!Painter!and!Decorator!PTY!LTD!!!!!!!!!!!!!!!Safe!Work!Method!Statement!
!ABN!31!169!646!780!!!!Licence!#!264495C!!!M:!0427!235!776!!!@:[email protected]!
HAZARDOUS SUBSTANCES TO BE USED ON SITE YES NO
Product Name: ALL PAINT PRODUCTS MSDS Attached Product Name MSDS Attached
YES NO YES NO
PERSONNEL DETAILS EQUIPMENT DETAILS
Qualifications Required Licenses, qualifications and permits must be current
Plant and Equipment required to do the job safely
Paint brush Platform Ladders
Spray gun Broom Lift
Gaps scissor Lift
Putty Scaffold
Sand paper
Planks
Any Additional Training Required YES NO
Details
Confined Space Entry If yes, mandatory Confined Spaces Entry Permit
YES NO
Working at Heights YES NO
Personal Protective Equipment
Hard Hat
Working at Depth YES NO Boots
Electrical Equipment Tagged YES NO Vests
Cranage YES NO Glasses
Dust/Noise etc YES NO Long Trousers/Sleeves
Power Supplies YES NO Full Face Protection
Underground Services YES NO Hearing Protection
Safety Barriers ect YES NO Sun Protection (hats,sunscreen
-
!!! !!
!
! Wayne!Mallison!Painter!and!Decorator!PTY!LTD!!!!!!!!!!!!!!!Safe!Work!Method!Statement!
!ABN!31!169!646!780!!!!Licence!#!264495C!!!M:!0427!235!776!!!@:[email protected]!
!