Picture Window
Double-Hung Window
Joined Combinations:
4
Measure from side jamb to side jamb at bottom, middle, and top of window. Record smallest width on worksheet.
Side JambSide Jamb
Measure from wood side jamb to wood side jamb.
Lower sash not shown for clarity.
Tape Measure
3-1/4"
Exterior
Before Measuring:
4
4
4
If any rotten wood on the frame of the original window cannot be repaired or replaced, opening will not be suitable for insert window replacement.
Existing opening must be plumb, level and square. If not, adjustments must be made to window size when ordering.
Make sure a 3-1/4" wide pocket exists or can be created for insert window.
Record measurements on “Measurement Worksheet”.
Describe window locations clearly and record measurements to nearest 1/8" when recording measurements.
Measure each window even if they appear the same size.
Woodwright® and tilt-wash insert windows can only be joined in 1-way combinations as shown below.
Vertical Joining
Horizontal Joining
1
0005441 BD Revised 01/21/11
Exterior
Measure from wood side jamb to wood side jamb.
Side JambSide Jamb
Tape Measure
1Interior
Measuring Information:
4
4
4
for 400 Series Woodwright®and Tilt-Wash Double-Hung & Picture Insert Windows
For questions call 1-888-888-7020 Monday - Friday, 7 a.m. to 7 p.m. and Saturday, 8 a.m. to 4 p.m. central time. For more information and/or guides visit andersenwindows.com.
Measurement Guide
Thank you for choosing Andersen.
▶▶ Read▶this▶measurement▶guide▶from▶beginning▶to▶end▶before▶beginning.▶Read▶all▶warnings▶and▶cautions▶during▶unit▶installation.▶▶▶▶ Read▶and▶follow▶product▶installation▶guide▶for▶installation▶instructions.▶▶
“Andersen” and all other marks where denoted are trademarks of Andersen Corporation. ©2006-2011 Andersen Corporation. All rights reserved.
Based on step 4, choose sill angle on worksheet.
0º Flat
8º Moderate
5
0º- 4º
5º- 10º
11º- 15º
Measure from top of sill, just behind stool, to underside of head jamb at sides and middle. Record smallest height on worksheet.
Tape Measure
(diagonals within 1/8")
Select on worksheet:
Measure angle of existing sill using Method 1 or Method 2. Record angle rounded to the nearest degree on worksheet.
Method 1
Method 2
Rise
4"
Sill
Measure rise over 4". Find sill angle on table.
4
14º Steep
Measure from corner to corner. Square openings use standard deductions and out-of-square use non-standard deductions (determined by you) to provide clearance during installation.
For square opening:
For out-of-square opening:
3Interior
Slide thin ruler behind stool (cut paint if needed) to measure stool height (B).
Height = A + B
Measure from wood head jamb to top of stool (A).
Measure from head jamb to sill.
(diagonals not within 1/8")Width deduction
Use a sill angle finder.
Rise 1/16" 1/8" 3/16" 1/4" 3/8" 7/16" 1/2" Angle 1º 2º 3º 4º 5º 6º 7º
9/16" 5/8" 11/16" 3/4" 7/8" 15/16" 1" 1-1/16" 8º 9º 10º 11º 12º 13º 14º 15º
Stool
Sill
Sill
Stool
Head Jamb
Ruler
Tape Measure
Heightdeduction
Tape Measure
Head Jamb
Angle Finder
2Interior
Insert window location
Select on worksheet:
Insert window will be built 3/8" narrower than opening width in and 1/4" shorter than opening height in to provide installation clearance.
Size insert window to provide clearance for level and square installation.
Record desired insert unit dimensions on worksheet.
1
2
Picture Window
Double-Hung Window
Measure directly behind stool.
B
A
Interior
Exterior
Thin Ruler
Andersen Sill Angle Finder
2
“Andersen” and all other marks where denoted are trademarks of Andersen Corporation. ©2006-2011 Andersen Corporation. All rights reserved.
Measurement Worksheetfor Andersen® 400 Series Woodwright® and Tilt-Wash Double-Hung and Picture Insert Window
Cust
omer
NAME PHONE
ADDRESS E-MAIL
CITY/STATE/ZIP ORDER DATE
Page of
non-tempered
interiorexterior
WindowLocation
Existing Opening & window size
Color& Finish
Insect Screens
GlassOptions
Grille Style & Size
Grille Pattern
new insert windowexisting opening
with no no spacer, removable between glassspacer spacer removable interior only interior
Divided Light removable Finelight™
66
white Terratone®
sandtone forest green
Low-E4® glass Low-E4® SmartSun™glass Low-E4® Sun glass
conventional
TruScene®
Part of joined combination(sketch joined)
3/4" 7/8" 1-1/8" 2-1/4" 3/4" 1" (Woodwright® divided light only)
Window #
4
(width) (height)
1STEP
Smallest measured width (to nearest 1/8")
2STEP
Smallest measured height (to nearest 1/8")
3STEP
(width) (height)
of
0005441
Notes and sketches
(sketch grille pattern)
Insert window will be 3/8" less in width and 1/4" less in height than recorded in & .
Standard deduction Non-standard deduction
(check only one)
Record desired insert unit dimension below to the nearest 1/8":
Sill Angledouble-hung and picture only
21
(width) (height)
4STEP
0º (0º- 4º)Measured sill angle: 8º (5º- 10º) 14º (11º- 15º)
Choose sill angle:5STEP
white maple (Woodwright® only)
pine oak (Woodwright® only)
equal cottage reverse cottage
half full
Single window
▶▶ See▶back▶side▶of▶worksheet▶for▶custom▶sizing▶tables.
Terratone®
forest green
HardwareEstate™ traditional
bright brass
antique brass
polished chrome
brushed chrome
satin nickel
oil rubbed bronze
distressed nickel
distressed bronze
bright brass
antique brass
polished chrome
brushed chrome
satin nickel
oil rubbed bronze
white
stone
Classic Series™
lock & keeper
Estate™
Classic Series™
(stone color for wood interiors or white color for white interiors)
double-hung sash lift(s) (optional)
1 2
1 2finger lift (pair)
bar lift
finger lift (pair)
hand lift
sash lift
hand lift
9-lite prairie A
6-lite prairie custom nonespecified equal light
tempered
4sketchpattern
sketchpattern
white
sandtone
Quantity needed of this window type:
Window Style & Sash Ratio
picturedouble-hung transom
(typically joined to top of double-hung or picture window)
none
Woodwright®
Tilt-Wash
(Woodwright® Only)
white stone
hand lift
finger lift (pair)
0005441
Page of
to
78" 77 1 ⁄2" 77"
0° 8° 14°
to to
Sill Angle
45 5 ⁄8"to
to
16 1 ⁄2"45 5 ⁄8"
to16 1 ⁄2"
78"to
11 1 ⁄2"
CUST
OM H
EIG
HTS
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
Cottage Reverse Cottage
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
CUSTOM WIDTHS
78" 77 1 ⁄2" 77"
0° 8° 14°
0° 8° 14°
27 3 ⁄4" 27 1 ⁄4" 26 3 ⁄4"
to to
0° 8° 14°
12 1 ⁄2" 12" 11 1 ⁄2"
to
68" 67 1 ⁄2" 67"
0° 8° 14°
0° 8° 14°
31 3 ⁄4" 31 1 ⁄4" 30 3 ⁄4"
to to
Sill Angle Sill Angle
to
78"
78"to
11 1 ⁄2"
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
11 1 ⁄2"
Woodwright® Insert Window Size Ranges
Double-Hung - Equal Sash
Picture
Custom size windows are
available in 1 ⁄ 8" increments.
Height limits for double-hung
and picture insert windows
depend on new insert window
sill angle.
For picture and transom insert
windows, either height or
width must be 68" or less and
height plus width cannot be
less then 28".to
78" 77 1 ⁄2" 77"
0° 8° 14°
to to
Sill Angle
45 5 ⁄8"to
to
16 1 ⁄2"45 5 ⁄8"
to16 1 ⁄2"
78"to
11 1 ⁄2"
CUST
OM H
EIG
HTS
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
Cottage Reverse Cottage
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
CUSTOM WIDTHS
78" 77 1 ⁄2" 77"
0° 8° 14°
0° 8° 14°
27 3 ⁄4" 27 1 ⁄4" 26 3 ⁄4"
to to
0° 8° 14°
12 1 ⁄2" 12" 11 1 ⁄2"
to
68" 67 1 ⁄2" 67"
0° 8° 14°
0° 8° 14°
31 3 ⁄4" 31 1 ⁄4" 30 3 ⁄4"
to to
Sill Angle Sill Angle
to
78"
78"to
11 1 ⁄2"
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
11 1 ⁄2"
to
78" 77 1 ⁄2" 77"
0° 8° 14°
to to
Sill Angle
45 5 ⁄8"to
to
16 1 ⁄2"45 5 ⁄8"
to16 1 ⁄2"
78"to
11 1 ⁄2"
CUST
OM H
EIG
HTS
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
Cottage Reverse Cottage
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
CUSTOM WIDTHS
78" 77 1 ⁄2" 77"
0° 8° 14°
0° 8° 14°
27 3 ⁄4" 27 1 ⁄4" 26 3 ⁄4"
to to
0° 8° 14°
12 1 ⁄2" 12" 11 1 ⁄2"
to
68" 67 1 ⁄2" 67"
0° 8° 14°
0° 8° 14°
31 3 ⁄4" 31 1 ⁄4" 30 3 ⁄4"
to to
Sill Angle Sill Angle
to
78"
78"to
11 1 ⁄2"
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
11 1 ⁄2"
to
78" 77 1 ⁄2" 77"
0° 8° 14°
to to
Sill Angle
45 5 ⁄8"to
to
16 1 ⁄2"45 5 ⁄8"
to16 1 ⁄2"
78"to
11 1 ⁄2"
CUST
OM H
EIG
HTS
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
Cottage Reverse Cottage
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
CUSTOM WIDTHS
78" 77 1 ⁄2" 77"
0° 8° 14°
0° 8° 14°
27 3 ⁄4" 27 1 ⁄4" 26 3 ⁄4"
to to
0° 8° 14°
12 1 ⁄2" 12" 11 1 ⁄2"
to
68" 67 1 ⁄2" 67"
0° 8° 14°
0° 8° 14°
31 3 ⁄4" 31 1 ⁄4" 30 3 ⁄4"
to to
Sill Angle Sill Angle
to
78"
78"to
11 1 ⁄2"
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
11 1 ⁄2"
Double-Hung - Cottage & Reverse Cottage Sash
Transom
to
78" 77 1 ⁄2" 77"
0° 8° 14°
to to
Sill Angle
44 7⁄8"to
to
21 1 ⁄4"44 7⁄8"
to21 1 ⁄4"
78"to
11 1 ⁄2"
CUST
OM H
EIG
HTS
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
Cottage Reverse Cottage
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
CUSTOM WIDTHS
91 3 ⁄4" 91 1 ⁄8" 90 5 ⁄8"
0° 8° 14°
0° 8° 14°
36 3 ⁄8" 35 3 ⁄4" 35 3 ⁄8"
to to
0° 8° 14°
12 1 ⁄2" 12" 11 1 ⁄2"
to
77 3 ⁄4" 77 1 ⁄4" 76 3 ⁄4"
0° 8° 14°
0° 8° 14°
43 3 ⁄8" 42 3 ⁄4" 42 1 ⁄4"
to to
Sill Angle Sill Angle
to
78"
78"to
11 1 ⁄2"
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
11 1 ⁄2"
Tilt-Wash Insert Window Size Ranges
Double-Hung - Equal Sash
Picture
to
78" 77 1 ⁄2" 77"
0° 8° 14°
to to
Sill Angle
44 7⁄8"to
to
21 1 ⁄4"44 7⁄8"
to21 1 ⁄4"
78"to
11 1 ⁄2"
CUST
OM H
EIG
HTS
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
Cottage Reverse Cottage
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
CUSTOM WIDTHS
91 3 ⁄4" 91 1 ⁄8" 90 5 ⁄8"
0° 8° 14°
0° 8° 14°
36 3 ⁄8" 35 3 ⁄4" 35 3 ⁄8"
to to
0° 8° 14°
12 1 ⁄2" 12" 11 1 ⁄2"
to
77 3 ⁄4" 77 1 ⁄4" 76 3 ⁄4"
0° 8° 14°
0° 8° 14°
43 3 ⁄8" 42 3 ⁄4" 42 1 ⁄4"
to to
Sill Angle Sill Angle
to
78"
78"to
11 1 ⁄2"
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
11 1 ⁄2"
to
78" 77 1 ⁄2" 77"
0° 8° 14°
to to
Sill Angle
44 7⁄8"to
to
21 1 ⁄4"44 7⁄8"
to21 1 ⁄4"
78"to
11 1 ⁄2"
CUST
OM H
EIG
HTS
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
Cottage Reverse Cottage
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
CUSTOM WIDTHS
91 3 ⁄4" 91 1 ⁄8" 90 5 ⁄8"
0° 8° 14°
0° 8° 14°
36 3 ⁄8" 35 3 ⁄4" 35 3 ⁄8"
to to
0° 8° 14°
12 1 ⁄2" 12" 11 1 ⁄2"
to
77 3 ⁄4" 77 1 ⁄4" 76 3 ⁄4"
0° 8° 14°
0° 8° 14°
43 3 ⁄8" 42 3 ⁄4" 42 1 ⁄4"
to to
Sill Angle Sill Angle
to
78"
78"to
11 1 ⁄2"
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
11 1 ⁄2"
to
78" 77 1 ⁄2" 77"
0° 8° 14°
to to
Sill Angle
44 7⁄8"to
to
21 1 ⁄4"44 7⁄8"
to21 1 ⁄4"
78"to
11 1 ⁄2"
CUST
OM H
EIG
HTS
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
Cottage Reverse Cottage
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
CUSTOM WIDTHS
91 3 ⁄4" 91 1 ⁄8" 90 5 ⁄8"
0° 8° 14°
0° 8° 14°
36 3 ⁄8" 35 3 ⁄4" 35 3 ⁄8"
to to
0° 8° 14°
12 1 ⁄2" 12" 11 1 ⁄2"
to
77 3 ⁄4" 77 1 ⁄4" 76 3 ⁄4"
0° 8° 14°
0° 8° 14°
43 3 ⁄8" 42 3 ⁄4" 42 1 ⁄4"
to to
Sill Angle Sill Angle
to
78"
78"to
11 1 ⁄2"
CUST
OM H
EIG
HTS
CUSTOM WIDTHS
11 1 ⁄2"
Double-Hung - Cottage & Reverse Cottage Sash
Transom