3DS
.CO
M©
Das
saul
tSys
tèm
es| C
onfid
entia
l Inf
orm
atio
n | 1
2/5/
2018
| ref
.: 3D
S_D
ocum
ent_
2015
EMC Simulation for
Automotive Ethernet
Dr Tamara Monti
Radio Technology SIG ‘EMC – Avoiding the nightmare’ Cambridge, December 4th 2018
2
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Active Exhaust Noise Suppression
Active Suspension
Active Vibration Control
Adaptive Cruise Control
Adaptive Front LightingAirbag Deployment
Antilock Braking
Autonomous Emergency Braking
Battery Management
Blind Spot Detection
Cabin Environment Controls
Entertainment System
Communication Systems
Convertible Top Control
Cylinder Deactivation
Driver Alertness Monitoring
Electronic Seat Control
Electronic Stability Control
Electronic Throttle Control
Electronic Toll Collection
Electronic Valve Timing
Engine ControlHead-Up Displays
Hill Hold Control
Idle Stop-Start
Instrument Cluster
Intelligent Turn Signals
Interior Lighting
Lane Departure WarningLane Keeping Assist
Navigation
Night Vision Systems
On-Board Diagnostics
Parking Systems
Precrash Safety
Rear-view Camera
Regenerative Braking
Remote Keyless Entry
Security Systems
Tire Pressure Monitoring
Traction Control
Traffic Sign Recognition
Transmission Control
Windshield Wiper Control
3
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Powertrain
• Latency: < 10 µs
• Bandwith: Low
• CAN
• FlexRay
Chassis
• Latency: < 10 µs
• Bandwith: Low
• CAN
• FlexRay
Body & Comfort
• Latency: < 10 ms
• Bandwith: Low
• CAN
• LIN
ADAS
• Latency: < 250 µs
• Bandwith: 50 Mbps per camera
• FlexRay
• MOST
• LVDS
• Ethernet
Infotainment
• Latency: < 10 ms
• Bandwith: High and growing
• Ethernet
In Vehicle Communication Standards
4
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Scope of EMC/EMI
kHz Inverter, Voltage Regulators MHz
Radio, Communication Systems
GHzDigital electronics, Radar
The ability of an electrical system to work
• in its electromagnetic environment
• without influencing the surrounding devices (emissions)
• or being influenced by surrounding equipment (susceptibility)
EMC compliance is crucial to all products!
• Susceptibility and emissions are a well regulated area
• Automotive OEM impose strict standards on components
5
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Conducted Emission Limits
From:
A GENERIC AUTOMOTIVE (TIER1)
EMC TEST STANDARD Martin O’Hara
The Automotive EMC Network, P.O. Box
3622, Newport Pagnell, MK16 0XT
http://www.autoemc.net/
6
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
EMC Simulation in the Design Process
EMC at all Stages of the Design Process
• multiple troubleshooting iterations
• high effort and costs to correct
• delayed time to market
Cost of
change
Time
Requirements Concept Product DevelopmentManufacturing
7
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Simulation Model
8
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
9
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
10
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
11
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
12
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
13
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
14
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
15
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Field Circuit Coupling
16
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
3D Full-Wave Solution
Finite Element Method
Frequency Domain
Adaptive Meshing
0-200 MHz in 60 samples
26 Ports
3h15m on dual Xeon E5-2643
28 GB RAM
17
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Decaps
IC
Signal Path
Connector
LISN
Reference
PCB as
Termination
IC
18
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
PRBS Signal & Spectrum
PRBS Signal PRBS Spectrum
Ideal differential driver
Use as source for AC simulation
19
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
BroadR vs. CAN
20
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Common and Differential Mode
21
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Modes on Differential PairCalculate the differential and common mode impedance
using a waveguide port
22
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Modes on Differential Pair
Differential 101 Ohm Common 35 Ohm
23
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Common and Differential Mode
Ideal Excitation
1V differential
1V common mode
24
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Current at Driver – 33 MHz
Differential ModeCommon Mode
25
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Current at Connector – 33 MHz
Differential ModeCommon Mode
26
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Common Mode
Differential to Common Mode Conversion
• Created due to non-ideal symmetry
• Only the common mode contributes to conducted emission
Timing
• Jitter and skew in signal generation
• Depends on the silicone
• No access for the electronic designer
Geometry
• Routing Constraints
• Connectors and cable bonding
27
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Conducted Emission
28
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Only ConnectorEmission at LISN N
29
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Cable Reference
Emission at LISN N
Emission at LISN N
30
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Cable SeparationEmission at LISN N
31
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Power Cables SidewardsEmission at LISN N
32
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Connector PinoutEmission at LISN N
33
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Untwisting at ConnectorEmission at LISN N
34
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Bad PCB Layout + Connector + UntwistingEmission at LISN N
35
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Countermeasures
36
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Common Mode Choke
37
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Common Mode ChokeCommon Mode at Rx IC
Emission at LISN N
38
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Common Mode
Differential to Common Mode Conversion
• Created due to non-ideal symmetry
• Only the common mode contributes to conducted emission
Timing
• Jitter and skew in signal generation
• Depends on the silicone
• No access for the electronic designer
Geometry
• Routing Constraints
• Connectors and cable bonding
39
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Signal Skew
0.1 ns skew
40
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Signal SkewEmission at LISN N
41
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Signal SkewEmission at LISN N
42
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Choke PositioningCommon Mode at Rx IC
Emission at LISN N
43
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Ferrite Clamp – Untwist longEmission at LISN N
beginning end
44
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
ShieldingEmission at LISN N
45
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
ShieldingEmission at LISN N
46
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Radiated Emission
47
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Radiated Emission Workflow
Far field probes All probe resultsWorst case envelope
48
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Cable ReferenceElectric Field @ 1m
49
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Connector PinoutEmission at LISN N
50
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Untwisting at ConnectorEmission at LISN N
51
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Power Cables SidewardsEmission at LISN N
52
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Bulk Current Injection
53
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15 TEST PROBE: Fischer Custom Communications F-130aFreq. range: 10kHz – 400MHz
http://www.fischercc.com
BCI Clamp
„Circuit Modeling of injection Probes for Bulk Current Injection“ by F. Grassi et al, IEEE Transactions on Electromagnetic Compatibility Vol. 49, Issue 3, 2007.
54
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
BCI ReferenceDifferential Signal at IC
300 mA injection
55
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
BCI ReferenceDifferential Signal at IC
300 mA injection
56
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
BCI Connector PinoutDifferential Signal at IC
57
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
BCI UntwistingDifferential Signal at IC
58
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
BCI UntwistingDifferential Signal at IC
59
3DS
.CO
M/S
IMU
LIA
© D
assa
ultS
ystè
mes
| Con
fiden
tial I
nfor
mat
ion
| 12/
5/20
18| r
ef.:
3DS
_Doc
umen
t_20
15
Summary
Automotive Ethernet
• Next generation signal bus
• Higher frequency content
Emission Simulation
• Early design stage
• Full-wave 3D coupled to circuit simulation
Results
• Understanding common mode is the key
• Layout can have significant effect on emission
• Untwisting of the TWP at the connector has a substantial effect on emission and susceptibility
• Not all countermeasures are efficient
60
3DS
.CO
M©
Das
saul
tSys
tèm
es| C
onfid
entia
l Inf
orm
atio
n | 1
2/5/
2018
| ref
.: 3D
S_D
ocum
ent_
2015