NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
Application• Combinationandnon-combinationmotorstartersareusedin
areaswherehazardousmaterialsarehandledorstored.• Theseunitsprovidedisconnectingmeans,undervoltage
protection,circuitprotection,andmotorrunningprotection.
Features• Copperfree cast aluminum.• Precisionmachinedflamepathbetweenboxandcover.• Bolt on slotted mounting feet.• Stainlesssteel,captiveQuad-Lead®coverbolts(disengagein
1-1/2turns).• Externalstainlesssteelbreakeroperatinghandle.• Ground lug package and installation instructions for termination
of ground wire enclosed.• Fourpointcontrolterminalblock,NEMA1Bwithwiremarkers.• Breaker operators can be locked in the ON or OFF position
(combinationstartersonly).• Fourplugged3/4”NPSMoutletsdrilledandtappedforcontrol
devices.• Standard outlets top and bottom.• Plugged1/2”outletstopandbottomforoptionalbreather/
drain.• Componentsaremountedonagalvanizedsteelremovable
pan.• EnclosuresaredesignedtoacceptCutler-Hammer✢,orSquare
Dmotorstarters/circuitbreakers.Forothermanufacturers,contact your local representative.
• O-ringgasketinsureswatertightintegrity.
Standard Materials• Bodiesandcovers:copperfree(4/10of1%)aluminum• Blockhinges,coverbolts,handle,breakerandoperatorshafts:
stainless steel• O-ring:neoprene
Standard Finish• Corrosion resistant gray powder coat epoxy inside and out
Options• Seemodificationspage.
NEC Certifications and Compliances• ANSI/ULStandards:UL508,UL50,UL1203• CSAStandards:C22.2No.0-10,C22.2No.14-10,
C22.2No.25-1996,C22.2No.30-M1986and C22.2No.94-M91
• cCSAusCertified:2561837
✢ Cutler-Hammer is a registered trademark of Eaton Corporation. Square D is a registered trademark of Schneider Electric.
NEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONT
ROLS
: NEC
/CEC
, ATE
X/IEC
Ex E
XPLO
SION
PROO
F/FL
AMEP
ROOF
CON
TROL
STA
TIONS
AND
SW
ITCHE
S
Visit our website at www.emerson.com or contact us at (800) 621-1506. © December 2016
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
Catalog Numbering GuideExample:ThepartnumberbelowdepictsanAppleton,ClassI,DivisionI,GroupsB,CandD,NEMASize1,Boltedtype,CombinationFullVoltageNonreversingMotorStarteroperatingat480Vac,Cutler-Hammer✢starterw/120Vaccontrolvoltage,andaCutler-Hammer7AMCP. Ifabreakerisnotrequired,omitlasttwocharacters.
AE 1 B B 4 W 1 C 2 ▲
NEC/CECCertified AESeries
Starter Function: A-FVNR(ATL)B-CombinationFVNRM-LightingContactor
(3-thru12-pole)N - Combination
Lighting Contactor (3-thru12-pole)
Optional Starter Function : C-FVRD-CombinationFVRE-2S1WF-Comb.2S1WG-2S2WH-Combination2S2WJ-Contactor(3pole)K-Combination
Contactor(3-pole)
ControlVoltage (120Vcoilstandard):1-120Vac2-240Vac3-380Vac4-480Vac6-600Vac8-480VCoil/120V
Control9-208Vac0-277Vac
Suffix for Other Options/Features:See Modifications
NEMASize:012345
OperatingVoltage:1-120Vac2-240Vac3-380Vac4-480Vac6-600Vac9-208Vac
Breaker Manufacturer: C-Cutler-HammerS-SquareD
EnclosureType:B Series
Starter Manufacturer: W-Standard;Eaton/
Cutler-Hammer(A200)
C-Freedom(AN16)BiMetal;Eaton/Cutler-Hammer and
A-Freedom(AN19)Electronic;Eaton/ Cutler-Hammer
S-SquareD
MCP or Breaker Trip:MCP
1-3Amp2-7Amp3-15Amp4-30Amp5-50Amp6-70Amp7-100Amp8-150Amp9-250Amp0-400Amp
Breaker Trip (ThermalMag):A-15AmpB-20AmpC-25AmpD-30AmpE-35AmpF-40AmpG-50AmpH-60AmpJ-70AmpK-80AmpM-90AmpN-100AmpP-125AmpQ-150AmpR-175AmpS-200AmpT-225AmpU-250AmpV-300AmpW-350AmpX-400Amp
Standard starter is manufactured by Square D; electrically operated, electrically held. Optional starter manufacture is ASCO; electrically operated, mechanically held. Contact your local sales representative for details.
Contact your local sales representative for details. Contact your local sales representative for additional UL Classified starters (Allen Bradley 509 and Vacuum, Sprecher and Schuh, Siemens, GE, and Cutler
Hammer ITT Softstart and V200 Vacuum).
NEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONTROLS: NEC/CEC, ATEX/IECEx EXPLOSIONPROOF/FLAMEPROOF CONTROL STATIONS AND SWITCHES
Visit our website at www.emerson.com or contact us at (800) 621-1506. © December 2016
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
NEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
Empty Enclosure
NEMA Size Catalog Number ▲
Approximate Weightkg (lb)
Standard Conduit (Inches)
Mounting Hardware Set Catalog Number
Full Voltage Nonreversing Enclosure Only
0 NE0BA 36(80)
1-1/2
NMH7
1 NE1BA 36(80)
2 NE2BA 39(85)
3 NE3BA 64(140) 2
4 NE4BA 64(140) 2-1/2
5 NE5BA 227(500) 4 NMH8
Dimensions in Millimeters (Inches) — Starter Only
Enclosure Layout for Size 0, 1 and 2 — Starter Only
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
Left Side View Front View Top View Bottom View
Enclosure Layout for Size 3 — Starter Only
L C
C L
RESET
2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
60 mm(2.38”)
2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
90 mm(3.13”)
90 mm(3.13”)
90 mm(3.13”)
311 mm (12.25”)Mounting
494 mm(19.44)
178 mm(7.00”)
235 mm(9.25”)
Mounting
Left View Front View
246 mm(9.69”)
289 mm(11.38”) 19 mm
(0.75”)359 mm (14.125)
702 mm(27.62”)
L C
C L
RESET
2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
60 mm(2.38”)
2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
90 mm(3.13”)
90 mm(3.13”)
90 mm(3.13”)
311 mm (12.25”)Mounting
494 mm(19.44)
178 mm(7.00”)
235 mm(9.25”)
Mounting
Left View Front View
246 mm(9.69”)
289 mm(11.38”) 19 mm
(0.75”)359 mm (14.125)
702 mm(27.62”)
L C
C L
RESET
2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
60 mm(2.38”)
2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
90 mm(3.13”)
90 mm(3.13”)
90 mm(3.13”)
311 mm (12.25”)Mounting
494 mm(19.44)
178 mm(7.00”)
235 mm(9.25”)
Mounting
Left View Front View
246 mm(9.69”)
289 mm(11.38”) 19 mm
(0.75”)359 mm (14.125)
702 mm(27.62”)
L C
C L
RESET
2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
60 mm(2.38”)
2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
90 mm(3.13”)
90 mm(3.13”)
90 mm(3.13”)
311 mm (12.25”)Mounting
494 mm(19.44)
178 mm(7.00”)
235 mm(9.25”)
Mounting
Left View Front View
246 mm(9.69”)
289 mm(11.38”) 19 mm
(0.75”)359 mm (14.125)
702 mm(27.62”)
Left Side View Front View Top View Bottom View
▲ To complete the catalog number please add the appropriate suffix for other options/features. Suffixes, see NEB Series Motor Starters Modifications.
CONT
ROLS
: NEC
/CEC
, ATE
X/IEC
Ex E
XPLO
SION
PROO
F/FL
AMEP
ROOF
CON
TROL
STA
TIONS
AND
SW
ITCHE
S
Visit our website at www.emerson.com or contact us at (800) 621-1506. © December 2016
Dimensions in Millimeters (Inches) — Starter Only
Enclosure Layout for Size 4 — Starter Only
RESET
L C
C L
2-1/2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
607 mm(23.88)
95 mm(3.75”)
95 mm(3.75”)
95 mm(3.75”)
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
489 mm(19.25”)
Mounting
Left View Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
310 mm (12.19)268 mm (10.56)
RESET
L C
C L
2-1/2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
607 mm(23.88)
95 mm(3.75”)
95 mm(3.75”)
95 mm(3.75”)
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
489 mm(19.25”)
Mounting
Left View Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
310 mm (12.19)268 mm (10.56) RESET
L C
C L
2-1/2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
607 mm(23.88)
95 mm(3.75”)
95 mm(3.75”)
95 mm(3.75”)
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
489 mm(19.25”)
Mounting
Left View Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
310 mm (12.19)268 mm (10.56)
RESET
L C
C L
2-1/2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
607 mm(23.88)
95 mm(3.75”)
95 mm(3.75”)
95 mm(3.75”)
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
489 mm(19.25”)
Mounting
Left View Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
310 mm (12.19)268 mm (10.56)
Left Side View Front View Top View Bottom View
Enclosure Layout for Size 5 — Starter Only C L
L C
RESET
Non-Combination Starter Size 5
Enclosure Layout
243 mm (9.56”)Cover Open 90º
Left View Front View
Top View
Bottom View
1” NPT4” NPT
546 mm (21.50”)Cover Open 130º
114 mm(4.50”)
114 mm(4.50”)
114 mm(4.50”)
4” NPT
1/2” NPTfor Breather
89 mm(3.50”)
89 mm(3.50”)
1/2” NPTfor Drain
864 mm(34.00”)
572 mm (22.50”)Mounting
19 mm(0.75”)
664 mm (26.13)
1168 mm(46.00”)
699 mm(27.50”)
Mounting
379 mm(14.94”)
421 mm(16.56”)
269 mm(10.60”)
C L
L C
RESET
Non-Combination Starter Size 5
Enclosure Layout
243 mm (9.56”)Cover Open 90º
Left View Front View
Top View
Bottom View
1” NPT4” NPT
546 mm (21.50”)Cover Open 130º
114 mm(4.50”)
114 mm(4.50”)
114 mm(4.50”)
4” NPT
1/2” NPTfor Breather
89 mm(3.50”)
89 mm(3.50”)
1/2” NPTfor Drain
864 mm(34.00”)
572 mm (22.50”)Mounting
19 mm(0.75”)
664 mm (26.13)
1168 mm(46.00”)
699 mm(27.50”)
Mounting
379 mm(14.94”)
421 mm(16.56”)
269 mm(10.60”)
C L
L C
RESET
Non-Combination Starter Size 5
Enclosure Layout
243 mm (9.56”)Cover Open 90º
Left View Front View
Top View
Bottom View
1” NPT4” NPT
546 mm (21.50”)Cover Open 130º
114 mm(4.50”)
114 mm(4.50”)
114 mm(4.50”)
4” NPT
1/2” NPTfor Breather
89 mm(3.50”)
89 mm(3.50”)
1/2” NPTfor Drain
864 mm(34.00”)
572 mm (22.50”)Mounting
19 mm(0.75”)
664 mm (26.13)
1168 mm(46.00”)
699 mm(27.50”)
Mounting
379 mm(14.94”)
421 mm(16.56”)
269 mm(10.60”)
C L
L C
RESET
Non-Combination Starter Size 5
Enclosure Layout
243 mm (9.56”)Cover Open 90º
Left View Front View
Top View
Bottom View
1” NPT4” NPT
546 mm (21.50”)Cover Open 130º
114 mm(4.50”)
114 mm(4.50”)
114 mm(4.50”)
4” NPT
1/2” NPTfor Breather
89 mm(3.50”)
89 mm(3.50”)
1/2” NPTfor Drain
864 mm(34.00”)
572 mm (22.50”)Mounting
19 mm(0.75”)
664 mm (26.13)
1168 mm(46.00”)
699 mm(27.50”)
Mounting
379 mm(14.94”)
421 mm(16.56”)
269 mm(10.60”)
Left Side View Front View Top View Bottom View
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
NEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONTROLS: NEC/CEC, ATEX/IECEx EXPLOSIONPROOF/FLAMEPROOF CONTROL STATIONS AND SWITCHES
Visit our website at www.emerson.com or contact us at (800) 621-1506. © December 2016
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
NEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
Empty Enclosure
NEMA Size Catalog Number ▲
Approximate Weightkg (lb)
Standard Conduit (Inches)
Mounting Hardware Set Catalog Number
Combination Full Voltage Nonreversing Enclosure Only
0 NE0BB 36(80)
1-1/2
NMH7
1 NE1BB 36(80)
2 NE2BB 39(85)
3 NE3BB 64(140)2-1/2
4 NE4BB 64(140)
5 NE5BB 227(500) 4 NMH8
Dimensions in Millimeters (Inches) — Combination
Enclosure Layout for Size 0, 1 and 2 — Combination
L C
C L
O F F N
O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N
O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N
O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N
O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
Left Side View Front View Top View Bottom View
Enclosure Layout for Size 3 and 4 — Combination
RESET
L C
C L
O F F N
O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm(3.75”)
95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
RESET
L C
C L
O F F N
O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm(3.75”)
95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
RESET
L C
C L
O F F N
O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm(3.75”)
95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
RESET
L C
C L
O F F N
O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm(3.75”)
95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
Left Side View Front View Top View Bottom View
▲ To complete the catalog number please add the appropriate suffix for other options/features. Suffixes, see NEB Series Motor Starters Modifications.
CONT
ROLS
: NEC
/CEC
, ATE
X/IEC
Ex E
XPLO
SION
PROO
F/FL
AMEP
ROOF
CON
TROL
STA
TIONS
AND
SW
ITCHE
S
Visit our website at www.emerson.com or contact us at (800) 621-1506. © December 2016
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
Dimensions in Millimeters (Inches) — Combination
Enclosure Layout for Size 5 — Combination C L
L C
RESET
O F F N
O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
C L
L C
RESET
O F F N
O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
C L
L C
RESET
O F F N
O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
C L
L C
RESET
O F F N
O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
Left Side View Front View Top View Bottom View
NEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONTROLS: NEC/CEC, ATEX/IECEx EXPLOSIONPROOF/FLAMEPROOF CONTROL STATIONS AND SWITCHES
Visit our website at www.emerson.com or contact us at (800) 621-1506. © December 2016
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
Full Voltage Motor Starter — Nonreversing — 3-Phase, 60 Hertz, 120 V Coil
Line Voltage
NEMA Size
Maximum Horsepower
Amp Trip Catalog Number ▲
Approximate Weight kg (lb)
Conduit Size (Inches)
Mounting Hardware Set Catalog Number
480
0 5 NA NE0BA4W1 36(80)
1-1/2
NMH7
1 10 NA NE1BA4W1 36(80)
2 25 NA NE2BA4W1 39(85)
3 50 NA NE3BA4W1 64(140) 2
4 100 NA NE4BA4W1 64(140) 2-1/2
5 200 NA NE5BA4W1 227(500) 4 NMH8
600
0 5 NA NE0BA6W1 57(125)
1-1/2
NMH7
1 10 NA NE1BA6W1 57(125)
2 25 NA NE2BA6W1 59(130)
3 50 NA NE3BA6W1 88(195) 2
4 100 NA NE4BA6W1 88(195) 2-1/2
5 200 NA NE5BA6W1 227(500) 4 NMH8
Wiring Diagrams
2-WIRE CONTROL ( OFF - ON SEL SW)
3-WIRE CONTROL (START & STOP )
2-WIRE CONTROL ( H-O-A SEL SW)
CONTROL OPTIONS
1
1
1STOP
M
SPACE HEATER
SPACE HEATER
(FOR SEPERATE 208V AND OVER ADD FUSE )
120V SEPARATE CONTROL
FULL VOLTAGE CONTROL
F
1
2
3
2
3
START
2
M
3
( SEE LEFT FOR CONTROL OPTIONS )
2
M
3
TRANSFORMER CONTROL
( SEE LEFT FOR CONTROL OPTIONS )STOPG
OL'SM X2
1
L1
F
H1H3H4 H2
CPT
F
2
1
3
X2
STOPG
RUNR
OL'SX2
L2
F( SEE TAP CHART ON TRANSFORMER )
X1
OFFHAND AUTO
ONOFF
STARTER
THHN/THWN
TYPE
XHHW-2XHHW-2
XHHW-2
L1, L2, L3
WIRE #
L1, L2, L3
L1, L2, L3
L1, L2, L3L1, L2, L3
POWER WIRE
0 #8#8
#1#6
43
3/0
12
SIZEWIRE
SIZE
BLACKBLACK
BLACKBLACKBLACK
COLOR
THHN/THWNXF
WIRE NUMBER
CONTROL WIRE
GNDCONTROL
X2
WIRE SIZE
GREENWHITE
RED
COLOR
RED#14
#14#14
TYPE
#14THHN/THWNTHHN/THWNTHHN/THWNTHHN/THWN
TYPEWIRE # COLORWIRE
#12SIZE
BLACKL1, L2
XFMR POWER WIRE
THHN/THWN
REMOTE
M
RUNRF
NON-COMBINATION STARTER - Size 0 thru 4
L1 L2
L1
L3
L2
M
M
M
OL
OL
OLMOTOR
T1
T3
T2
F F
1 2 3
OL'SX2
STOPG
SPACE HEATER
M
CR
L1 L2
321STOP
M
START
1 3
2
( SEE LEFT FOR CONTROL OPTIONS )
CPT
FX1 X2
H4 H2 H3 H1
CONTROL OPTIONS
3-WIRE CONTROL (START & STOP )
2-WIRE CONTROL ( H-O-A SEL SW)
FF
FOR 120V STARTER COIL
NON-COMBINATION STARTER - Size 5
( SEE LEFT FOR CONTROL OPTIONS )1 2 3 X2
FULL VOLTAGE CONTROLFOR 480V STARTER COILFULL VOLTAGE CONTROL
F
120V SEPARATE CONTROL
(FOR 240V AND OVER ADD FUSE)
L1 L2
REMOTE
OFFHAND AUTO
M
RUNR
OL'S
STOPG
SPACE HEATER
CRM
CR
RUNR
STARTER TYPE
XHHW-2BLACK5 (2) 3/0 L1, L2, L3
WIRE #
POWER WIRE
SIZEWIRE
SIZE COLOR XFWIRE NUMBER
CONTROL WIRE
GNDCONTROL
X2
WIRE SIZE
GREENWHITE
RED
COLOR
RED#14
#14#14
TYPE
#14THHN/THWNTHHN/THWNTHHN/THWNTHHN/THWN
TYPEWIRE # COLORWIRE
#12SIZE
BLACKL1, L2
XFMR POWER WIRE
THHN/THWN
120V
H2
F
H4
CPT
120V X2
H3 H1
F
F
M
L3
L1 L2
M
L1
L2M
MCT
OL
T3
T1
T2MOTOR
▲ To complete the catalog number please add the appropriate suffix for other options/features. Suffixes, see NEB Series Motor Starters Modifications.
NEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONT
ROLS
: NEC
/CEC
, ATE
X/IEC
Ex E
XPLO
SION
PROO
F/FL
AMEP
ROOF
CON
TROL
STA
TIONS
AND
SW
ITCHE
S
Visit our website at www.emerson.com or contact us at (800) 621-1506. © December 2016
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
NEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
Dimensions in Millimeters (Inches) — Starter Only
Enclosure Layout for Size 0, 1 and 2 — Starter Only
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
Left Side View Front View Top View Bottom View
Enclosure Layout for Size 3 — Starter Only
L C
C L
RESET
2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
60 mm(2.38”)
2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
90 mm(3.13”)
90 mm(3.13”)
90 mm(3.13”)
311 mm (12.25”)Mounting
494 mm(19.44)
178 mm(7.00”)
235 mm(9.25”)
Mounting
Left View Front View
246 mm(9.69”)
289 mm(11.38”) 19 mm
(0.75”)359 mm (14.125)
702 mm(27.62”)
L C
C L
RESET
2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
60 mm(2.38”)
2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
90 mm(3.13”)
90 mm(3.13”)
90 mm(3.13”)
311 mm (12.25”)Mounting
494 mm(19.44)
178 mm(7.00”)
235 mm(9.25”)
Mounting
Left View Front View
246 mm(9.69”)
289 mm(11.38”) 19 mm
(0.75”)359 mm (14.125)
702 mm(27.62”)
L C
C L
RESET
2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
60 mm(2.38”)
2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
90 mm(3.13”)
90 mm(3.13”)
90 mm(3.13”)
311 mm (12.25”)Mounting
494 mm(19.44)
178 mm(7.00”)
235 mm(9.25”)
Mounting
Left View Front View
246 mm(9.69”)
289 mm(11.38”) 19 mm
(0.75”)359 mm (14.125)
702 mm(27.62”)
L C
C L
RESET
2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
60 mm(2.38”)
2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
90 mm(3.13”)
90 mm(3.13”)
90 mm(3.13”)
311 mm (12.25”)Mounting
494 mm(19.44)
178 mm(7.00”)
235 mm(9.25”)
Mounting
Left View Front View
246 mm(9.69”)
289 mm(11.38”) 19 mm
(0.75”)359 mm (14.125)
702 mm(27.62”)
Left Side View Front View Top View Bottom View
CONTROLS: NEC/CEC, ATEX/IECEx EXPLOSIONPROOF/FLAMEPROOF CONTROL STATIONS AND SWITCHES
Visit our website at www.emerson.com or contact us at (800) 621-1506. © December 2016
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
Dimensions in Millimeters (Inches) — Starter Only
Enclosure Layout for Size 4 — Starter Only
RESET
L C
C L
2-1/2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
607 mm(23.88)
95 mm(3.75”)
95 mm(3.75”)
95 mm(3.75”)
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
489 mm(19.25”)
Mounting
Left View Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
310 mm (12.19)268 mm (10.56)
RESET
L C
C L
2-1/2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
607 mm(23.88)
95 mm(3.75”)
95 mm(3.75”)
95 mm(3.75”)
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
489 mm(19.25”)
Mounting
Left View Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
310 mm (12.19)268 mm (10.56) RESET
L C
C L
2-1/2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
607 mm(23.88)
95 mm(3.75”)
95 mm(3.75”)
95 mm(3.75”)
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
489 mm(19.25”)
Mounting
Left View Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
310 mm (12.19)268 mm (10.56)
RESET
L C
C L
2-1/2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
607 mm(23.88)
95 mm(3.75”)
95 mm(3.75”)
95 mm(3.75”)
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
489 mm(19.25”)
Mounting
Left View Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
310 mm (12.19)268 mm (10.56)
Left Side View Front View Top View Bottom View
Enclosure Layout for Size 5 — Starter Only C L
L C
RESET
Non-Combination Starter Size 5
Enclosure Layout
243 mm (9.56”)Cover Open 90º
Left View Front View
Top View
Bottom View
1” NPT4” NPT
546 mm (21.50”)Cover Open 130º
114 mm(4.50”)
114 mm(4.50”)
114 mm(4.50”)
4” NPT
1/2” NPTfor Breather
89 mm(3.50”)
89 mm(3.50”)
1/2” NPTfor Drain
864 mm(34.00”)
572 mm (22.50”)Mounting
19 mm(0.75”)
664 mm (26.13)
1168 mm(46.00”)
699 mm(27.50”)
Mounting
379 mm(14.94”)
421 mm(16.56”)
269 mm(10.60”)
C L
L C
RESET
Non-Combination Starter Size 5
Enclosure Layout
243 mm (9.56”)Cover Open 90º
Left View Front View
Top View
Bottom View
1” NPT4” NPT
546 mm (21.50”)Cover Open 130º
114 mm(4.50”)
114 mm(4.50”)
114 mm(4.50”)
4” NPT
1/2” NPTfor Breather
89 mm(3.50”)
89 mm(3.50”)
1/2” NPTfor Drain
864 mm(34.00”)
572 mm (22.50”)Mounting
19 mm(0.75”)
664 mm (26.13)
1168 mm(46.00”)
699 mm(27.50”)
Mounting
379 mm(14.94”)
421 mm(16.56”)
269 mm(10.60”)
C L
L C
RESET
Non-Combination Starter Size 5
Enclosure Layout
243 mm (9.56”)Cover Open 90º
Left View Front View
Top View
Bottom View
1” NPT4” NPT
546 mm (21.50”)Cover Open 130º
114 mm(4.50”)
114 mm(4.50”)
114 mm(4.50”)
4” NPT
1/2” NPTfor Breather
89 mm(3.50”)
89 mm(3.50”)
1/2” NPTfor Drain
864 mm(34.00”)
572 mm (22.50”)Mounting
19 mm(0.75”)
664 mm (26.13)
1168 mm(46.00”)
699 mm(27.50”)
Mounting
379 mm(14.94”)
421 mm(16.56”)
269 mm(10.60”)
C L
L C
RESET
Non-Combination Starter Size 5
Enclosure Layout
243 mm (9.56”)Cover Open 90º
Left View Front View
Top View
Bottom View
1” NPT4” NPT
546 mm (21.50”)Cover Open 130º
114 mm(4.50”)
114 mm(4.50”)
114 mm(4.50”)
4” NPT
1/2” NPTfor Breather
89 mm(3.50”)
89 mm(3.50”)
1/2” NPTfor Drain
864 mm(34.00”)
572 mm (22.50”)Mounting
19 mm(0.75”)
664 mm (26.13)
1168 mm(46.00”)
699 mm(27.50”)
Mounting
379 mm(14.94”)
421 mm(16.56”)
269 mm(10.60”)
Left Side View Front View Top View Bottom View
NEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONT
ROLS
: NEC
/CEC
, ATE
X/IEC
Ex E
XPLO
SION
PROO
F/FL
AMEP
ROOF
CON
TROL
STA
TIONS
AND
SW
ITCHE
S
Visit our website at www.emerson.com or contact us at (800) 621-1506. © December 2016
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
NEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
Combination Full Voltage Motor Starters With Motor Circuit Protector (MCP) — Nonreversing — 3-Phase, 60 Hertz, 120 V Coil
Line Voltage
NEMA Size
Maximum Horsepower
Amp Trip Catalog Number ▲
Approximate Weightkg (lb)
Conduit Size (Inches)
Mounting Hardware Set Catalog Number
480
0
1 3 NE0BB4W1C1 57(125)
1-1/2
NMH7
3 7 NE0BB4W1C2 57(125)
5 15 NE0BB4W1C3 57(125)
17 15 NE1BB4W1C3 57(125)
10 30 NE1BB4W1C4 59(130)
212 30 NE2BB4W1C4 59(130)
25 50 NE2BB4W1C5 59(130)
330 50 NE3BB4W1C5 88(195)
2-1/250 100 NE3BB4W1C7 88(195)
4 100 150 NE4BB4W1C8 88(195)
5 200 400 NE5BB4W1C0 227(500) 4 NMH8
600
0
1 3 NE0BB6W1C1 57(125)
1-1/2
NMH7
3 7 NE0BB6W1C2 57(125)
5 15 NE0BB6W1C3 57(125)
17 15 NE1BB6W1C3 57(125)
10 30 NE1BB6W1C4 57(125)
220 30 NE2BB6W1C4 59(130)
25 50 NE2BB6W1C5 59(130)
340 50 NE3BB6W1C5 88(195)
2-1/250 100 NE3BB6W1C7 88(195)
460 100 NE4BB6W1C7 88(195)
100 150 NE4BB6W1C8 88(195)
5 200 400 NE5BB6W1C0 227(500) 4 NMH8
▲ To complete the catalog number please add the appropriate suffix for other options/features. Suffixes, see NEB Series Motor Starters Modifications.
CONTROLS: NEC/CEC, ATEX/IECEx EXPLOSIONPROOF/FLAMEPROOF CONTROL STATIONS AND SWITCHES
Visit our website at www.emerson.com or contact us at (800) 621-1506. © December 2016
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
Combination Full Voltage Motor Starters With Motor Circuit Protector (MCP) — Nonreversing— 3-Phase, 60 Hertz, 120 V Coil
Wiring Diagram
2-WIRE CONTROL ( OFF - ON SEL SW)
3-WIRE CONTROL (START & STOP )
2-WIRE CONTROL ( H-O-A SEL SW)
CONTROL OPTIONS
1
1
1STOP
M
SPACE HEATER
SPACE HEATER
(FOR SEPERATE 208V AND OVER ADD FUSE )
120V SEPARATE CONTROL
FULL VOLTAGE CONTROL
F
1
2
3
2
3
START
2
M
3
( SEE LEFT FOR CONTROL OPTIONS )
2
M
3
TRANSFORMER CONTROL
( SEE LEFT FOR CONTROL OPTIONS )STOPG
OL'SM X2
1
L1
F
H1H3H4 H2
CPT
F
2
1
3
X2
STOPG
RUNR
OL'SX2
L2
F( SEE TAP CHART ON TRANSFORMER )
X1
OFFHAND AUTO
ONOFF
STARTER
THHN/THWN
TYPE
XHHW-2XHHW-2
XHHW-2
L1, L2, L3
WIRE #
L1, L2, L3
L1, L2, L3
L1, L2, L3L1, L2, L3
POWER WIRE
0 #8#8
#1#6
43
3/0
12
SIZEWIRE
SIZE
BLACKBLACK
BLACKBLACKBLACK
COLOR
THHN/THWNXF
WIRE NUMBER
CONTROL WIRE
GNDCONTROL
X2
WIRE SIZE
GREENWHITE
RED
COLOR
RED#14
#14#14
TYPE
#14THHN/THWNTHHN/THWNTHHN/THWNTHHN/THWN
TYPEWIRE # COLORWIRE
#12SIZE
BLACKL1, L2
XFMR POWER WIRE
THHN/THWN
REMOTE
M
RUNRF
L1
L2
L3
COMBINATION STARTER - Size 1 thru 4
L1 L2
CB
M
M
M
MOTOR
OL
OL
OL
T1
T3
T2
F F
1 2 3
OL'SX2
STOPG
SPACE HEATER
M
CR
L1 L2
321STOP
M
START
1 3
2
( SEE LEFT FOR CONTROL OPTIONS )
CPT
FX1 X2
H4 H2 H3 H1
CONTROL OPTIONS
3-WIRE CONTROL (START & STOP )
2-WIRE CONTROL ( H-O-A SEL SW)
FF
L3
L1
L2M
L2L1
CB CT
M
M
FOR 120V STARTER COIL
COMBINATION STARTER - Size 5
( SEE LEFT FOR CONTROL OPTIONS )1 2 3 X2
FULL VOLTAGE CONTROLFOR 480V STARTER COILFULL VOLTAGE CONTROL
F
120V SEPARATE CONTROL
(FOR 240V AND OVER ADD FUSE)
L1 L2
REMOTE
OFFHAND AUTO
M
RUNR
OL'S
STOPG
SPACE HEATER
CRM
CR
RUNR
STARTER TYPE
XHHW-2BLACK5 (2) 3/0 L1, L2, L3
WIRE #
POWER WIRE
SIZEWIRE
SIZE COLOR XFWIRE NUMBER
CONTROL WIRE
GNDCONTROL
X2
WIRE SIZE
GREENWHITE
RED
COLOR
RED#14
#14#14
TYPE
#14THHN/THWNTHHN/THWNTHHN/THWNTHHN/THWN
TYPEWIRE # COLORWIRE
#12SIZE
BLACKL1, L2
XFMR POWER WIRE
THHN/THWN
120V
OL
T3
T1
T2MOTOR
H2
F
H4
CPT
120V X2
H3 H1
F
F
M
NEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONT
ROLS
: NEC
/CEC
, ATE
X/IEC
Ex E
XPLO
SION
PROO
F/FL
AMEP
ROOF
CON
TROL
STA
TIONS
AND
SW
ITCHE
S
Visit our website at www.emerson.com or contact us at (800) 621-1506. © December 2016
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
NEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
Dimensions in Millimeters (Inches) — CombinationEnclosure Layout for Size 0, 1 and 2 — Combination
L C
C L
O F F N
O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N
O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N
O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N
O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
Left Side View Front View Top View Bottom View
Enclosure Layout for Size 3 and 4 — Combination
RESET
L C
C L
O F F N
O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm(3.75”)
95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
RESET
L C
C L
O F F N
O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm(3.75”)
95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
RESET
L C
C L
O F F N
O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm(3.75”)
95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
RESET
L C
C L
O F F N
O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm(3.75”)
95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
Left Side View Front View Top View Bottom View
Enclosure Layout for Size 5 — CombinationC L
L C
RESET
O F F N
O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
C L
L C
RESET
O F F N
O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
C L
L C
RESET
O F F N
O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
C L
L C
RESET
O F F N
O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
Left Side View Front View Top View Bottom View
CONTROLS: NEC/CEC, ATEX/IECEx EXPLOSIONPROOF/FLAMEPROOF CONTROL STATIONS AND SWITCHES
Visit our website at www.emerson.com or contact us at (800) 621-1506. © December 2016
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
NEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
Combination Full Voltage Motor Starters with Thermal Magnetic Circuit Breaker – Nonreversing — 3-Phase, 60 Hertz, 120 V Coil
Line Voltage
NEMA Size
Maximum Horsepower
Amp Trip Catalog Number ▲
Approximate Weightkg (lb)
Conduit Size (Inches)
Mounting Hardware Set Catalog Number
480
03 15 NE0BB4W1CA 57(125)
1-1/2
NMH7
5 20 NE0BB4W1CB 57(125)
17-1/2 30 NE1BB4W1CD 57(125)
10 35 NE1BB4W1CE 57(125)
220 50 NE2BB4W1CG 59(130)
25 70 NE2BB4W1CJ 59(130)
350 100 NE3BB4W1CN 88(195)
2-1/260 125 NE3BB4W1CP 88(195)
475 150 NE4BB4W1CQ 88(195)
100 200 NE4BB4W1CS 88(195)
5
125 250 NE5BB4W1CU 227(500)
4 NMH8150 300 NE5BB4W1CV 227(500)
200 400 NE5BB4W1CX 227(500)
600
0 5 15 NE0BB6W1CA 57(125)
1-1/2
NMH7
17-1/2 20 NE1BB6W1CB 57(125)
10 30 NE1BB6W1CD 57(125)
215 40 NE2BB6W1CF 59(130)
25 50 NE2BB6W1CG 59(130)
330 70 NE3BB6W1CJ 88(195)
2-1/250 100 NE3BB6W1CN 88(195)
475 125 NE4BB6W1CP 88(195)
100 150 NE4BB6W1CQ 88(195)
5150 250 NE5BB6W1CU 227(500)
4 NMH8200 300 NE5BB6W1CV 227(500)
▲ To complete the catalog number please add the appropriate suffix for other options/features. Suffixes, see NEB Series Motor Starters Modifications.
CONT
ROLS
: NEC
/CEC
, ATE
X/IEC
Ex E
XPLO
SION
PROO
F/FL
AMEP
ROOF
CON
TROL
STA
TIONS
AND
SW
ITCHE
S
Visit our website at www.emerson.com or contact us at (800) 621-1506. © December 2016
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
Combination Full Voltage Motor Starters with Thermal Magnetic Circuit Breaker – Nonreversing — 3-Phase, 60 Hertz, 120 V Coil
Wiring Diagram
2-WIRE CONTROL ( OFF - ON SEL SW)
3-WIRE CONTROL (START & STOP )
2-WIRE CONTROL ( H-O-A SEL SW)
CONTROL OPTIONS
1
1
1STOP
M
SPACE HEATER
SPACE HEATER
(FOR SEPERATE 208V AND OVER ADD FUSE )
120V SEPARATE CONTROL
FULL VOLTAGE CONTROL
F
1
2
3
2
3
START
2
M
3
( SEE LEFT FOR CONTROL OPTIONS )
2
M
3
TRANSFORMER CONTROL
( SEE LEFT FOR CONTROL OPTIONS )STOPG
OL'SM X2
1
L1
F
H1H3H4 H2
CPT
F
2
1
3
X2
STOPG
RUNR
OL'SX2
L2
F( SEE TAP CHART ON TRANSFORMER )
X1
OFFHAND AUTO
ONOFF
STARTER
THHN/THWN
TYPE
XHHW-2XHHW-2
XHHW-2
L1, L2, L3
WIRE #
L1, L2, L3
L1, L2, L3
L1, L2, L3L1, L2, L3
POWER WIRE
0 #8#8
#1#6
43
3/0
12
SIZEWIRE
SIZE
BLACKBLACK
BLACKBLACKBLACK
COLOR
THHN/THWNXF
WIRE NUMBER
CONTROL WIRE
GNDCONTROL
X2
WIRE SIZE
GREENWHITE
RED
COLOR
RED#14
#14#14
TYPE
#14THHN/THWNTHHN/THWNTHHN/THWNTHHN/THWN
TYPEWIRE # COLORWIRE
#12SIZE
BLACKL1, L2
XFMR POWER WIRE
THHN/THWN
REMOTE
M
RUNRF
L1
L2
L3
COMBINATION STARTER - Size 1 thru 4
L1 L2
CB
M
M
M
MOTOR
OL
OL
OL
T1
T3
T2
F F
1 2 3
OL'SX2
STOPG
SPACE HEATER
M
CR
L1 L2
321STOP
M
START
1 3
2
( SEE LEFT FOR CONTROL OPTIONS )
CPT
FX1 X2
H4 H2 H3 H1
CONTROL OPTIONS
3-WIRE CONTROL (START & STOP )
2-WIRE CONTROL ( H-O-A SEL SW)
FF
L3
L1
L2M
L2L1
CB CT
M
M
FOR 120V STARTER COIL
COMBINATION STARTER - Size 5
( SEE LEFT FOR CONTROL OPTIONS )1 2 3 X2
FULL VOLTAGE CONTROLFOR 480V STARTER COILFULL VOLTAGE CONTROL
F
120V SEPARATE CONTROL
(FOR 240V AND OVER ADD FUSE)
L1 L2
REMOTE
OFFHAND AUTO
M
RUNR
OL'S
STOPG
SPACE HEATER
CRM
CR
RUNR
STARTER TYPE
XHHW-2BLACK5 (2) 3/0 L1, L2, L3
WIRE #
POWER WIRE
SIZEWIRE
SIZE COLOR XFWIRE NUMBER
CONTROL WIRE
GNDCONTROL
X2
WIRE SIZE
GREENWHITE
RED
COLOR
RED#14
#14#14
TYPE
#14THHN/THWNTHHN/THWNTHHN/THWNTHHN/THWN
TYPEWIRE # COLORWIRE
#12SIZE
BLACKL1, L2
XFMR POWER WIRE
THHN/THWN
120V
OL
T3
T1
T2MOTOR
H2
F
H4
CPT
120V X2
H3 H1
F
F
M
NEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONTROLS: NEC/CEC, ATEX/IECEx EXPLOSIONPROOF/FLAMEPROOF CONTROL STATIONS AND SWITCHES
Visit our website at www.emerson.com or contact us at (800) 621-1506. © December 2016
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
NEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
Dimensions in Millimeters (Inches) — CombinationEnclosure Layout for Size 0, 1 and 2 — Combination
L C
C L
O F F N
O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N
O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N
O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N
O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
Left Side View Front View Top View Bottom View
Enclosure Layout for Size 3 and 4 — Combination
RESET
L C
C L
O F F N
O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm(3.75”)
95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
RESET
L C
C L
O F F N
O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm(3.75”)
95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
RESET
L C
C L
O F F N
O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm(3.75”)
95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
RESET
L C
C L
O F F N
O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm(3.75”)
95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
Left Side View Front View Top View Bottom View
Enclosure Layout for Size 5 — CombinationC L
L C
RESET
O F F N
O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
C L
L C
RESET
O F F N
O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
C L
L C
RESET
O F F N
O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
C L
L C
RESET
O F F N
O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
Left Side View Front View Top View Bottom View
CONT
ROLS
: NEC
/CEC
, ATE
X/IEC
Ex E
XPLO
SION
PROO
F/FL
AMEP
ROOF
CON
TROL
STA
TIONS
AND
SW
ITCHE
S
Visit our website at www.emerson.com or contact us at (800) 621-1506. © December 2016
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
Lighting Contactor — 3-Pole — 60 Hertz, 120 V Coil
Line Voltage
Emclosure Size
Contactor Amps
Number of Poles Catalog Number ▲
Approximate Weightkg (lb)
Conduit Size (Inches)
Mounting Hardware Set
Catalog Number
120 1 30
3 NE1BM1S13
57(125) 1-1/2 NMH76 NE1BM1S16
9 NE1BM1S19
12 NE1BM1S112
Wiring Diagram
(SEE TAP CHART ON XFMR) F
G OFF
R ON
ON R
OFF G
F F
L1 L2
120V SEPARATE CONTROL
(FOR 208V AND OVER ADD FUSE )
CPT
F 1 X2
H4 H2 H3 H1
L1 L2
L2
L3
L1
C
C
C
NON-COMBINATION CONTACTOR
FULL VOLTAGE CONTROL
WIRING SHOWN FOR 3 POLES ONLY
F
3
2
HAND
1
AUTO OFF
X2
HAND
1
2
AUTO OFF
3 X2
TRANSFORMER CONTROL
ON OFF
ON
3 2
OFF 1
3 1
CONTROL OPTIONS
2-POSITION SELECTOR SWITCH CONTROL
PUSHBUTTON CONTROL
X1
M
C
SPACE HEATER
C
PC
PC
SPACE HEATER
PC
C
PC
C
Dimensions in Millimeters (Inches) — Lighting Contactor C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
Left Side View Front View Top View Bottom View
▲ To complete the catalog number please add the appropriate suffix for other options/features. Suffixes, see NEB Series Motor Starters Modifications.
NEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONTROLS: NEC/CEC, ATEX/IECEx EXPLOSIONPROOF/FLAMEPROOF CONTROL STATIONS AND SWITCHES
Visit our website at www.emerson.com or contact us at (800) 621-1506. © December 2016
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
Combination Lighting Contactor — 3-Pole — 60 Hertz, 120 V Coil
Line Voltage
Emclosure Size
Contactor Amps
Contactor Amps
Number of Poles Catalog Number ▲
Approximate Weightkg (lb)
Conduit Size (Inches)
Mounting Hardware Set
Catalog Number
120 1 30 40
3 NE1BN1S1F3
57(125) 1-1/2 NMH76 NE1BN1S1F6
9 NE1BN1S1F9
12 NE1BN1S1F12
Wiring Diagram
(SEE TAP CHART ON XFMR) F
G OFF
R ON
ON R
OFF G
F F
L1 L2
120V SEPARATE CONTROL
(FOR 208V AND OVER ADD FUSE )
CPT
F 1 X2
H4 H2 H3 H1
FULL VOLTAGE CONTROL
WIRING SHOWN FOR 3 POLES ONLY
F
3
2
HAND
1
AUTO OFF
X2
HAND
1
2
AUTO OFF
3 X2
TRANSFORMER CONTROL
ON OFF
ON
3 2
OFF 1
3 1
CONTROL OPTIONS
2-POSITION SELECTOR SWITCH CONTROL
PUSHBUTTON CONTROL
X1
M
C
SPACE HEATER
C
PC
PC
SPACE HEATER
PC
C
PC
C
L3
L2
L1
CB
C
C
C
L2L1
COMBINATION LTG. CONTACTOR
Dimensions in Millimeters (Inches) — Combination Lighting ContactorL C
C L
O F F N
O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N
O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N
O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N
O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
Left Side View Front View Top View Bottom View
▲ To complete the catalog number please add the appropriate suffix for other options/features. Suffixes, see NEB Series Motor Starters Modifications.
NEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONT
ROLS
: NEC
/CEC
, ATE
X/IEC
Ex E
XPLO
SION
PROO
F/FL
AMEP
ROOF
CON
TROL
STA
TIONS
AND
SW
ITCHE
S
Visit our website at www.emerson.com or contact us at (800) 621-1506. © December 2016
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
Modifications
Description
Suffix Factory Installed
Catalog Number
Field Installed
Operators
Start/Stop dual push button S3X NEPDGRE
Stop push button S2X NEPRC
Start push button S1X NEPGA
Stop,lightedPB,red120Vac LP5X NEPTRE
Start,lightedPB,green120Vac LP4X NEPTGE
3positionselectorswitchspecifylegend A3X NESS31MN
2positionselectorswitchspecifylegend A2X NESS22ML
Redpilotlight,120Vac L5 NEPL1R
Greenpilotlight,120Vac L4 NEPL1G
Redpilotlight,240Vac L52 NEPL2R
Greenpilotlight,240Vac L42 NEPL2G
Redpilotlight,480Vac L54 NEPL4R
Greenpilotlight,480Vac L44 NEPL4G
NEMA 4X Breather/Drain Fittings
Drainfitting DN DRNB4X
Breather fitting (Drilled and tapped installation included.)
BR BRTB4X
Control Power Options
FusedCPT,50Va T1 NFCPT050
FusedCPT,100Va T2 NFCPT100
FusedCPT,200Va T3 NFCPT200
FusedCPT,250Va T4 NFCPT250
FusedCPT,50Vaw/interposingrelay T5 NFCPT050R
FusedCPT,150Va T6 NFCPT150
FusedCPT,300Va T7 NFCPT300
FusedCPT,500Va T8 NFCPT500
FusedCPT,750Va T9 NFCPT750
Separate control fused circuit S-120V n/a
Specify starter coil voltage S-240V n/a
S-480V n/a
Description
Suffix Factory Installed
Catalog Number
Field Installed
Nameplates
Engravednameplate—blacklettersonwhitesurface,50.8x101.6mm(2”x4”),3.18mm(0.125”)letters,3linesmax. specify legend
NP n/a
Space Heater
40Wattenclosurespace heaters
120Vac O-120V NFA4327X11
240Vac O-240V NFA4327X12
480Vac O-480V NFA4327X13
Control Terminal Blocks (Above 12 points contact your local representative)
20Amp,600Vac 8point 8K n/a
NEMA1Bw/wiremarkers 12point 12K n/a
Cutler-Hammer ✢ Starter Auxiliary Contacts
Size0-41NO/1NC X11C NJ-11
2NO/2NC X22C NJ-11 (2ea.)
Size51NO/1NC X511C N3463D94G18
2NO/2NC X522C N3463D94G18 (2ea.)
Square D Starter Auxiliary Contacts
Size0-51NO/1NC X11S A999SX8
2NO/2NC X22S A999SX8 (2ea.)
Number of Poles on Lighting Contactors
30Amp,120Vac 3Poles 3
30Amp,120Vac 6Poles 6
30Amp,120Vac 9Poles 9
30Amp,120Vac 12Poles 12
NOTE: CPT includes primary and secondary fuses. Add —L to part no. for Size 5 starters. Size 1 and 2 150 Vac Max. Size 3 and 4 300 Vac Max. Contact your local representative for other voltages. 8 Aux. Contacts Max. includes one seal-in and seven added. 4 Aux. Contacts Max. includes one seal-in and three added. Size 0-1 includes one seal-in and four added. Size 2-5 includes one seal-in and three added.✢ Cutler-Hammer is a registered trademark of Eaton Corporation. Square D is a registered trademark of Schneider Electric.
NEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONTROLS: NEC/CEC, ATEX/IECEx EXPLOSIONPROOF/FLAMEPROOF CONTROL STATIONS AND SWITCHES
Visit our website at www.emerson.com or contact us at (800) 621-1506. © December 2016